Charging Abnormal(Battery Over Charging Or Over Discharging) - PGO G-MAX 50 Service Manual

13.Charging abnormal(battery over charging or over discharging)

Check and adjust
Measure battery's
Voltage then start
engine
Check voltage rectifier
Plug is loose or not
Check the voltage
Between chassisΘand
The red cable♁of
Voltage rectifier
Check the resistivity
Of A.C. generator coil
Start engine, connect
green cable to
Chassis, then measure
the voltage between
chassisΘand red cable♁
of voltage of
rectifier
Check the connection
Of the cable of
Voltage rectifier
Check the resistivity
Of the body of
Voltage rectifier
Trouble condition
Voltage remain
The same
good
good
normal
charging abnormal (over charging)
Voltage higher
Than specification
good
Out of spec
Voltage goes up
To normal value,
But after engine
Stop, the voltage
Goes down again
loosen
No voltage
abnormal
Voltage normal
Poor connection
The reason
battery is dead
battery malfunction
poor connection
red cable disconnected
voltage rectifier
malfunction
white cable disconnect
defective coil
poor connection
A.C. generator's
white cable
disconnected
cable poor connection
poor connection of
green cable
Voltage rectifier
faulty