Fuel/Oil Systems; Fuel Tank; Fuel Fill And Vent - Pro-Line Boats 32 Express 2006 Owner's Manual

The raw water washdown hose is located in a compartment on the
starboard side of the baitwell tub and just below the sink. When the
washdown pump is on, twist the nozzle on the end of the hose to
turn the water on and off and check to see if the washdown sprays.
You can adjust the pressure or stream of the spray by turning the
nozzle clockwise for a tighter stream or counterclockwise for more
of a spray pattern. This spray nozzle can also be used at the
freshwater sink located next to the baitwell tub.
After checking for water and before returning the washdown hose to the storage compartment, turn off the
washdown pump at the helm to release the water pressure in the hose. Twisting the hose clockwise
allows you to easily stow the hose away.
The round filter attached to the side of the washdown pump should be removed and cleaned often with
running water.

Fuel/Oil Systems

Fuel Tank

The 300-gallon fuel tank on your Pro-Line is constructed of heavy gauge aluminum with internal baffling
to minimize sloshing. The fuel tank is located under the deck and is secured between the stringers and
bulkheads.
Starboard
Port Engine Manufacturers Generator Engine Pick-Up
Fuel Pick-Up Label Pick-Up
Inspect the hose connections on a regular basis. To access the fuel fill and fuel vent hoses at the tank,
go into the mid berth and remove the round access pie located on the right side of the window opening.
The other end of these two hoses can be accessed via the 6" deck plate that is installed just below the
fuel fill on the inside the cockpit.

Fuel Fill and Vent

The fuel fill is a stainless steel fitting labeled "Gas" or "Fuel" and is located
approximately admidships on the starboard gunwale. Twist the cap to open
the fitting. The cap is connected to the fitting by a chain or cable so that it
will not fall into the water and/or get lost. Be careful not to pump fuel into
any other fitting on the vessel.
The external fuel vent is located just below the fuel fill on the outside of the
hull, and the gas tank is vented overboard. While you are filling the tank,
fuel entering the tank pushes air in the tank out through the fuel vent.
38