Suzuki DF40A Manual page 5

NOTE
For the items with asterisk (*) in the "CONTENTS" below, refer to the same section of the service manual
mentioned in the "FOREWORD" of this manual.
General Information ................................ 0A-1
General Description ............................................. 0A-*
Symbols ...............................................................0A-*
Abbreviations .......................................................0A-*
Wire Color Symbols .............................................0A-*
Warning, Caution and Information Label
Locations............................................................0A-*
Genuine Parts Description ...................................0A-*
Outboard Motor Identification Number
Location .............................................................0A-*
Fuel and Oil Recommendations...........................0A-*
Break-In Procedures ............................................0A-*
Propeller Selection Guide ....................................0A-*
Battery Requirement ............................................0A-*
Specifications.......................................................0A-1
Specifications .......................................................0A-*
Service Data ........................................................0A-*
Tightening Torque Specifications.........................0A-*
Specifications (DF40A/50A) ................................ 0A-1
Specifications (DF40AS/DF60A)......................... 0A-3
Service Data (DF40A/50A/60A) .......................... 0A-5
Tightening Torque Specifications (DF40A/
50A/60A) ......................................................... 0A-10
Special Tools and Equipment ............................. 0A-*
Recommended Service Material ..........................0A-*
Special Tool .........................................................0A-*
Maintenance and Tune-Up...................... 0B-1
Precautions........................................................... 0B-*
Precautions for Maintenance ...............................0B-*
Section 0
General Information
CONTENTS
General Description ............................................. 0B-*
Recommended Oil and Lubricants...................... 0B-*
Scheduled Maintenance ......................................0B-1
Periodic Maintenance Schedule Chart................ 0B-*
Lubrication Point ................................................. 0B-*
Periodic Maintenance Schedule Chart
(DF40A/50A/60A)..............................................0B-1
Service Instructions ............................................. 0B-*
Engine Oil Level Check....................................... 0B-*
Engine Oil Change and Engine Oil Filter
Replacement ..................................................... 0B-*
Gear Oil Change ................................................. 0B-*
Spark Plug Removal and Installation .................. 0B-*
Spark Plug Inspection and Cleaning ................... 0B-*
Tappet Clearance Inspection and Adjustment .... 0B-*
Idle Speed and Idle Air Control (IAC) Duty
Inspection.......................................................... 0B-*
Ignition Timing Inspection ................................... 0B-*
Breather Line and Fuel Line Inspection .............. 0B-*
Low Pressure Fuel Filter Inspection.................... 0B-*
Water Pump and Water Pump Impeller
Inspection.......................................................... 0B-*
Propeller / Propeller Nut and Cotter Pin
Inspection.......................................................... 0B-*
Anodes Inspection............................................... 0B-*
Bonding Wires Inspection ................................... 0B-*
Battery Inspection ............................................... 0B-*
Bolts and Nuts Inspection ................................... 0B-*
Oil Pressure Check ............................................. 0B-*
Cylinder Compression Pressure Check .............. 0B-*
Table of Contents 0- i
0