Travis Industries Spirit 300 GS Service Manual page 27

Avanti (1995,1996) B-Vent
Remove the door following
the directions to the right.
Remove the glass following
the directions to the right.
Replace the glass following
the directions to the right.
Travis Industries
Door & Glass Removal
The door hangs on a pair of hooks on both
sides. Lift the door up and off the hooks to
remove. To replace, align the brackets on the
door over the hooks and slide downwards until
the door locks in place.
Center
Glass
DV's Only
b
Remove the glass trim on both sides.
Center
Lower Glass Clips
Top
View
DV's Only
Glass Trim (make sure both pieces
of glass butt up against the trim)
Gas T-Shoot Guide
(ser. # 2503 - 5730)
Door
Loosen the three glass clips
a
holding the side glass in place.
Slide the side glass to the rear
Do these steps for both sides.
Side
Glass
Place one hand on the glass.
Loosen the four nuts on the bottom
glass clip until the glass can be tilted forward and removed.
Upper Glass Clips
Glass
Right
Side
Glass
Center
Glass
Right
Side
Glass
& DV (
ser. # 1004 - 33188)
Hooks on Side
of Heater
Bracket (on back
side of door)
c
Remove the top glass clip.
Cross Section of Glass Attachment
Glass Clip
Attachment Studs
Glass
Clip
Nuts
Face of
Heater
Glass Clip
Glass Gasket
(5/8" self-adhesive
channel gasket)
Glass
Side Glass Clip
Glass
The side glass has gasket attached to the
Gasket top, bottom and outward sides. The center
glass has gasket on the top and bottom.
Left Center
Glass
Side
Glass
3 - 3
Right
Side
Glass
19203