UniCarriers FRSB14-8 Operation & Maintenance Manual page 107

■ ■
LUBRICATING LIFT CHAIN LUBRICATING LIFT CHAIN
Apply Apply engine engine
brush. To allow oil to enter between each pin and link brush. To allow oil to enter between each pin and link
plate of the lift chain, observe the following conditions: plate of the lift chain, observe the following conditions:
Lower the forks Lower the forks
• •
sufciently. sufciently.
After applying engine After applying engine
• •
fully at least 10 times. fully at least 10 times.
NOTE NOTE
If your lift truck is used near a port or coastal area, If your lift truck is used near a port or coastal area,
the lift chains might be damaged by salty breeze. the lift chains might be damaged by salty breeze.
After a storm or typhoo After a storm or
with fresh water before lubricating in the manner with fresh water before lubricating in the manner
described above. described above.
■ ■
APPLYING GREASE ON THE MAST APPLYING GREASE ON THE MAST
WARNING WARNING
Do not climb the mast. Do not put your hand Do not climb the mast. Do not put your hand
or foot on the connecting members or into the or foot on the connecting members or into the
mast assembly. You might get injured if the mast mast assembly. You might get injured if the mast
moves moves accidentally. accidentally
1 1
1. 1. SLIPPER SLIPPER
2. 2. END END ROLLER ROLLER
oil oil to to the the lift lift chains chains using using
on the ground and loosen on the ground and loosen
oil, move oil, move the mast up the mast up
typhoon, it is advisable t n, it is advisable
.
2 2 3 3
3. 3.
4. 4.
https://www.forkliftpdfmanuals.com/
PERIODIC INSPECTION PERIODIC INSPECTION
a a lubricator lubricator or or
the chains the chains
and down and down
1 1 : :
to wash them o wash them
Apply grease on the surfaces (hatched areas) Apply grease on the surfaces (hatched areas)
over which the end rollers, side rollers and over which the end rollers, side rollers and
slippers roll. slippers roll.
SIDE SIDE ROLLER ROLLER
INNER INNER CHANNEL CHANNEL
4-13 4-13
CHAIN CHAIN
4 4
5 5 6 6
5. 5. INTERMEDIATE INTERMEDIATE
6. 6. OUTER OUTER CHANNEL CHANNEL
1 1
CHANNEL CHANNEL