Engine, General; Air Filter, Change - Volvo Penta D5 Operator's Manual

Maintenance
P0013783
40

Engine, General

General inspection
Make a habit of visually checking the engine and
engine bay before starting, and after operations when
you have stopped the engine. This will help you to
quickly discover abnormalities, or if something is about
to happen.
Look especially carefully for oil, fuel and coolant
leakages, loose bolts, worn or poorly-tensioned drive
belts, loose cable connections, damaged electrical
cables and hoses. This inspection only takes a few
minutes and can prevent serious malfunctions and
expensive repairs.
WARNING!
Risk of fire.
Remove all accumulations of fuel, oil and grease when
detected on the engine or in the engine room.
WARNING!
If an oil, fuel or coolant leak is detected, the cause must
be investigated and the fault rectified before the engine
is started.
Never direct the jet from a high-pressure washer at
seals, rubber hoses or electrical components. Never
use the high pressure setting for engine cleaning.

Air Filter, Change

1 If indicator is all red after the engine is stopped,
change the filter insert.
2 Undo the hose clamp below the air filter cartridge
and pull off the cartridge.
3 Replace the air filter cartridge and tighten the hose
clamp.
4 Press the button on the service indicator to reset
the signal after service. The indicator is now ready
to operate again.
IMPORTANT!
Scrap the old filter. It must not be cleaned.
47713336 03-2021 © AB VOLVO PENTA