Safety Precautions; General Safety Rules And Regulations - SaMASZ KDC 260 Operator's Manual

4. SAFETY PRECAUTIONS

and followed by every person who operates or maintains the machine. Failure to follow these
safety precautions could result in serious injury or death to the operator, maintenance person or
bystanders and property damage to the machine and surrounding property.
Safety Signal Words
This manual and the safety labels attached to this equipment utilize signal words that signify
safety hazards with different levels of severity. Below are the words used and the definitions
for these words:
• DANGER indicates a hazardous situation which, if not avoided, will result in death
or serious injury.
WARNING indicates a hazardous situation which, if not avoided, could result in
•
death or serious injury.
CAUTION indicates a hazardous situation which, if not avoided, could result in
•
minor or moderate injury.
NOTE is used to address practices not related to physical injury.
•
4.1.

General safety rules and regulations

The following descriptions are for your safety: They must therefore be read carefully
and applied every time you use the machine.
The machine has been designed for use by one single operator.
When using, servicing, repairing, moving or storing the machine, the operator must wear safety
footwear, safety gloves plus ear protection and dusk mask if necessary.
During use, the machine may give rise to dust, especially if the soil is dry. You are advised to
use a tractor with a cab fitted with filters in the ventilation system. Failing this, wear a dust
mask with filter to protect your respiratory tract
Front axis of the tractor should be weighted to keep the balance. If need be, use front wheel
weights.
In order to keep steering conditions, impact on front axis should be at least 20% of the complete
tractor.
Be extremely careful whenever using hydraulic lift lever or buttons. Any operation with
hydraulic lift lever should be done from operator's seat; DO NOT move the lever from outside
of a tractor.
In case of tractors equipped with EHR, operating with hydraulic lift is done by the buttons
mounted outside the tractor's cabin. When operating be extremely careful.
When switching from mowing to transport position, remove the entire PTO shaft or at least one
end of the shaft from the tractor's PTO so it cannot turn.
When attaching the mower to a tractor, the operator should wear protective gloves.
DO NOT operate the mower unless all safety guards are in place and operational. In addition,
any damaged protective aprons should be replaced with a new one
Start mowing only when tractor's PTO reaches its normal 1000 rpm. DO NOT exceed 1050
PTO rpm.
No person (except operator) should stand within danger area which is a minimum of 164' 1"
from any operating part, especially when operating near roads and in areas with stones and other
Be certain that children and animals are at a safe distance away from the machine
debris.
Operator's manual
The following precautions are for your safety. They must be read carefully
Trailed disc mowers
- 11 -
KDC
.