Miscellaneous Engine Troubleshooting; Battery Charger (Solid State); Table 4-6 Miscellaneous Engine Troubleshooting; Table 4-7 Battery Charger (Solid State) - Carrier RG2059 Series Operation And Service

4.1.6

Miscellaneous Engine Troubleshooting

Condition
Loss of power
Vibration
Overheating
Excessive crankcase pressure Plugged crankcase breather line
4.2

BATTERY CHARGER (SOLID STATE)

Condition
CB4 trips when charger is
turned on
Circuit breaker
repeatedly, even when not
connected
Charger does not taper back
after charging for a
minutes
T-361
Table 4–6 Miscellaneous Engine Troubleshooting
Possible Cause
Restriction in air cleaner
Air in fuel system
Air vent restricted
Restricted fuel lines
Fuel injection pump is bad
Injector(s) bad or incorrect type used
Incorrect fuel injection pump timing
Incorrect valve timing
Poor compression
Engine shockmounts are bad
Poor compression
Restriction in air cleaner
Exhaust pipe restriction
Restriction in water jacket
Restriction in radiator
Coolant level too low
Loose water pump/alternator poly V-belt
Thermostat is bad
Water pump is bad
Table 4–7 Battery Charger (Solid State)
Possible Cause
Short in 12-volt wiring causing overload of
charger
trips Internal short
Bad cell in battery
few
Charger is bad
Section 5.5.11
Section 5.5.11
Clean
Engine Manual
Engine Manual
Engine Manual
Engine Manual
Engine Manual
Engine Manual
Replace
Engine Manual
Section 5.5.11
Remove
Engine Manual
Section 5.5.5
Section
Section 5.5.10
Engine Manual
Engine Manual
Section 5.5.12
Locate
replace charger
Replace charger
Test battery for defect according to
battery manufacturer's instructions
Replace
4–4
Remedy/Reference Section
2.11.
Remedy/Reference Section
and remove short or