Installation - Technogel Mixpasto 60 Use And Maintenance Instructions

3.5

INSTALLATION

The following rules must be respected during installation:
Placement
Place the machine onto a flat and solid surface.
Avoid the direct exposure to sunbeams and nearby heat sources.
Leave at least 50 cm of free space in front of the grids to enable the perfect functioning of the refrigeration
system.
Set-up
The machine is supplied with all its parts permanently installed.
Connection to water mains
Connect the water piping of the cooling circuit to the fittings accessible from the rear of the machine and
identified by the specific wording (see Fig. 3.2a).
Use water from the well or the mains with temperature below 30°C. The guaranteed flow rate must be  500
l/h. The machine pressure valve regulates the flow of the condenser's cooling water.
Then connect the water pipe for washing hand shower (fig. 3.2b)
Fig. 3.2a
Connection to electric mains
The power supply system must have a 5-pole socket for 3N three-phase power supply for 400 V and at 4-
poles 3F for 220 V voltages of approved type.
The current socket must be protected by a type B residual current device calibrated at 300 mA, by a circuit
breaker suitable for the currents indicated in tab. 2.1, and be equipped with earth connection.
Check the mains voltage and frequency correspond to those required by the machine, indicated on the EC
plate or technical manual.
Connect the machine using the power plug to the power supply. This must be close and easily accessible
and managed by the operator
A main switch must be provided in the socket or in an easily accessible place, that completely disconnects
voltage from the socket (isolation) and enables the interaction or execution of operations requiring access to
moving parts (see fig. 3.3.).
Fig. 3.3
THIS MANUAL IS THE PROPERTY OF
Fig. 3.2b
The electrical system for powering the machine must be perfect.
The manufacturer is not liable for inadequate power supply and
earthing system and/or non-conform to standards.
Only enabled personnel can connect the electrical parts.
–
TECHNOGEL SpA
ALL REPRODUCTIONS, EVEN PARTIAL, ARE FORBIDDEN
12
Page 12 of 52