Troubleshooting Guide - Taylor-Dunn C0-014-32 Operation, T Roubleshooting And Replacement Parts Manual

Troubleshooting Guide

Symptom
Steering Pulls in One Direction
Hard Steering
Excessive Steering Play
Lack of Power or Slow Operation
Abnormal Noise
Oil Leak in Rear Bearing Area
Brake Pedal Soft or Spongy
Brake Pedal Low
Braking Power Low
Note: This list is provided as a guide only. It is not all inclusive of causes that may result in a specific
symptom.
Maintenance, Service and Repair
Probable Cause
Front End Out of Alignment
Low Tire Pressure
Dry Lube Points in Steering Linkage
Damaged King Pin/Ball Joint
Low Tire Pressure
Worn Ball Joints
Mis-Adjusted or Worn Steering Gear
Loose Steering Linkage
Brakes or Parking Brakes Dragging
Batteries Discharged or Defective
Worn Drive Gears
Front End Out of Alignment
Defective Speed Control
Worn Drive Gears or Bearings
Worn Front /Rear Axle Bearings
Loose Lug Nuts
Motor Bearings Worn
Rear Wheel Bearing and/or Gasket Failed
Drive Over Filled
Air in Brake Lines
Brake Worn (1/16" Wear Limit)
Brake Fluid Low
Brakes Out of Adjustment
Brake Worn (1/16" Wear Limit)
Brake Pads Contaminated with Fluid
Brake Pedal Linkage Binding
Brakes Out of Adjustment
Air in Brake Lines
Page 3