Checking The Canister; Checking The Coolant Level; Checking The Cooling System - Yamaha 2009 XP500Y TMAX Service Manual

4. Install:
• Bottom cowling
Refer to "GENERAL CHASSIS" on page 4-1.
EAS21090

CHECKING THE CANISTER

1. Remove:
• Storage box
Refer to "GENERAL CHASSIS" on page 4-1.
• Fuel tank
Refer to "FUEL TANK" on page 7-1.
2. Check:
• Canister "1"
• Canister purge hoses "2"
Cracks/damage → Replace.
2
2
3. Install:
• Fuel tank
Refer to "FUEL TANK" on page 7-1.
• Storage box
Refer to "GENERAL CHASSIS" on page 4-1
EAS21110

CHECKING THE COOLANT LEVEL

1. Stand the vehicle on a level surface.
TIP
• Place the vehicle on the centerstand.
• Make sure the vehicle is upright.
2. Check:
• Coolant level
The coolant level should be between the
maximum level mark "a" and minimum level
mark "b".
1
3-17
Below the minimum level mark → Add the
recommended coolant to the proper level.
ECA13470
NOTICE
• Adding water instead of coolant lowers the
antifreeze content of the coolant. If water is
used instead of coolant check, and if nec-
essary, correct the antifreeze concentra-
tion of the coolant.
• Use only distilled water. However, if dis-
tilled water is not available, soft water may
be used.
3. Start the engine, warm it up for several min-
utes, and then turn it off.
4. Check:
• Coolant level
TIP
Before checking the coolant level, wait a few
minutes until it settles.
EAS21120

CHECKING THE COOLING SYSTEM

1. Remove:
• Bottom cowling
• Footrest boards
Refer to "GENERAL CHASSIS" on page 4-1.
2. Check:
• Radiator "1"
• Radiator inlet hose "2"
• Radiator outlet hose "3"
• Oil cooler inlet hose "4"
• Oil cooler outlet hose "5"
• Oil cooler "6"
• Thermostat outlet hose "7"
• Water pump "8"
• Oil cooler hose "9"
• Water pump inlet pipe "10"
• Water pump outlet pipe "11"
Cracks/damage → Replace.
Refer to "RADIATOR" on page 6-1, "THER-
MOSTAT" on page 6-7 and "WATER PUMP"
on page 6-9.
ENGINE
a
b