Yamaha VX600ERG Service Manual page 7

CHAPTER 6.
COOLING SYSTEM
HEAT EXCHANGER ........................................ 6-1
VX600ER/SX600/VT600 ............................ 6-1
MM600 ........................................................ 6-2
INSPECTION .............................................. 6-3
INSTALLATION .......................................... 6-4
WATER PUMP .................................................. 6-5
REMOVAL .................................................. 6-6
INSPECTION .............................................. 6-6
INSTALLATION .......................................... 6-6
CHAPTER 7.
CARBURETION
CARBURETORS .............................................. 7-1
INSPECTION .............................................. 7-5
ASSEMBLY ................................................ 7-6
CARBURETOR SYNCHRONIZATION ....... 7-7
FUEL LEVEL ADJUSTMENT ..................... 7-8
INSTALLATION .......................................... 7-9
FUEL PUMP ................................................... 7-10
VX600ER/VT600 ...................................... 7-10
SX600/MM600 .......................................... 7-11
INSPECTION ............................................ 7-12
INSTALLATION ........................................ 7-12
CHAPTER 8.
ELECTRICAL
SWITCH INSPECTION ..................................... 8-1
SWITCH INSPECTION .............................. 8-1
INSPECTING A SWITCH SHOWN IN THE
MANUAL ..................................................... 8-1
IGNITION SYSTEM .......................................... 8-2
CIRCUIT DIAGRAM ................................... 8-2
TROUBLESHOOTING ............................... 8-4
CONDENSER (SX600/MM600) ................. 8-6
AC MAGNETO ........................................... 8-6
SPARK PLUG ............................................. 8-7
SPARK PLUG CAP .................................... 8-7
IGNITION COIL .......................................... 8-7
THROTTLE OVERRIDE SYSTEM
(T.O.R.S.) ................................................... 8-8
HANDLEBAR SWITCH (RIGHT) ................ 8-8
CARBURETOR SWITCH ........................... 8-9
MAIN SWITCH ........................................... 8-9
LOAD CONTROL RELAY ........................ 8-10
EMERGENCY ENGINE STARTING
(SX600/MM600) ....................................... 8-10
ELECTRICAL STARTING SYSTEM
(VX600ER/VT600) .......................................... 8-11
CIRCUIT DIAGRAM ................................. 8-11
TROUBLESHOOTING ............................. 8-12
MAIN SWITCH ......................................... 8-13
STARTER MOTOR .................................. 8-14
CHARGING SYSTEM (VX600ER/VT600) ...... 8-18
CIRCUIT DIAGRAM ................................. 8-18
TROUBLESHOOTING ............................. 8-19
BATTERY ................................................. 8-20
STATOR COIL .......................................... 8-20
LIGHTING SYSTEM ....................................... 8-22
CIRCUIT DIAGRAM ................................. 8-22
TROUBLESHOOTING ............................. 8-24
BULB(S) ................................................... 8-26
HEADLIGHT BEAM SWITCH ................... 8-26
HEADLIGHT RELAY ................................ 8-27
SIGNAL SYSTEM ........................................... 8-28
CIRCUIT DIAGRAM ................................. 8-28
TROUBLESHOOTING ............................. 8-30
BRAKE LIGHT SWITCH ........................... 8-34
GEAR POSITION SWITCH
(VX600ER/VT600) .................................... 8-34
DC BACK BUZZER (VX600ER/VT600) ... 8-34
WATER TEMPERATURE SENSOR ........ 8-35
OIL LEVEL SWITCH ................................ 8-36
FUEL SENDER ........................................ 8-36
GRIP WARMER SYSTEM .............................. 8-38
CIRCUIT DIAGRAM ................................. 8-38
TROUBLESHOOTING ............................. 8-40
GRIP AND THUMB WARMER COIL ........ 8-42
VARIABLE RESISTOR
(THUMB WARMER) ................................. 8-42
VARIABLE RESISTOR
(GRIP WARMER) ..................................... 8-43