Table Of Contents - Quadra-Fire SAPH-MBK-IPI Installation Manual

Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Installation Standard work Checklist . . . . . . . . . . . . . . . . . . . . 3
1 Product Specific and Important Safety Information
a. appliance Certification . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
B. glass Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
C. BtU Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
d. high altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 4
e. Non-Combustible Materials Specification. . . . . . . . . . . . . . 4
F. Combustible Materials Specification . . . . . . . . . . . . . . . . . 4
g. electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
h. Requirements for the Commonwealth of Massachusetts . . 5
2 Getting Started
a. design and Installation Considerations . . . . . . . . . . . . . . . 6
B. tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . . 6
C. Inspect appliance and Components . . . . . . . . . . . . . . . . . . 6
3 Framing and Clearances
a. appliance dimension diagram . . . . . . . . . . . . . . . . . . . . . . 7
B. Clearances to Combustibles . . . . . . . . . . . . . . . . . . . . . . . 8
C. hearth extension/Floor Protection . . . . . . . . . . . . . . . . . . . 8
4 Termination Location and Vent Information
a. Vent termination Minimum Clearances . . . . . . . . . . . . . . . 9
B. Chimney diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
C. approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
d. Use of elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
e. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
F. Venting guidelines for horizontal Runs . . . . . . . . . . . . . . 13
g. Vent diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
5 Vent Clearances and Framing
a. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 30
B. Wall Penetration Framing/Firestops . . . . . . . . . . . . . . . . . 30
C. Ceiling Firestop/Floor Penetration Framing . . . . . . . . . . . 31
d. Install attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 31
6 Appliance Preparation
a. top to Rear Vent Conversion . . . . . . . . . . . . . . . . . . . . . . 32
B. Securing and leveling the appliance . . . . . . . . . . . . . . . . 35
2 Quadra-Fire • SAPH-MBK-IPI, SAPH-D-PMH-IPI, SAPH-D-MBK-IPI, SAPH-D-CSB-IPI Installation Manual • 2343-980_R8 • 11/14

Table of Contents

7 Venting and Chimneys
a. assemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 36
B. assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 37
C. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 38
d. disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 38
e. Vertical termination Requirements . . . . . . . . . . . . . . . . . . 40
F. horizontal termination Requirements . . . . . . . . . . . . . . . 42
8 Electrical Information
a. general Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
B. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
9 Gas Information
a. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
B. gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
C. gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
d. high altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 48
e. air Shutter Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
10 Appliance Setup
a. Remove Fixed glass assembly . . . . . . . . . . . . . . . . . . . . 50
B. Remove the Shipping Materials . . . . . . . . . . . . . . . . . . . . 50
C. Clean the appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
d. Install the log assembly. . . . . . . . . . . . . . . . . . . . . . . . . . 51
e. Install Fixed glass assembly . . . . . . . . . . . . . . . . . . . . . . 52
11 Reference Materials
 a. Vent Components diagrams . . . . . . . . . . . . . . . . . . . . . . 53
B. accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
 = Contains updated information.