Dodge ram truck 3500 1996 Service Manual page 26

0 - 8 LUBRICATION AND MAINTENANCE
M A I N T E N A N C E
S C H E D U L E S — M E P i y H P U T Y
W E H I C L E 5
INDE1
page
GENERAL INFORMATION
I N T R O D U C T I O N 8
M E D I U M D U T Y S C H E D U L E — A . . . . 8
G E N E R A L I M F O R l ^ - L ' ^ M
INTRODUCTION
The following is a list of Maintenance Schedules
for Medium Duty Cycle vehicles (8.0L 2500 and 3500
Models •— California Only).
There are two maintenance schedules that show
proper service based on the conditions that the vehi­
cle is subjected to. Use the schedule that best
describes these conditions.
Schedule—A, lists all the scheduled maintenance
to be performed under normal operating conditions
for Medium Duty vehicles.
Schedule—B, lists maintenance recommended for
Medium Duty vehicles operated under the following
conditions:
• Frequent short trip driving less than 5 miles (8
km)
• Frequent driving in dusty conditions
• Frequent trailer towing
• Extensive idling
• More than 50% of your driving is at sustained
high speeds during hot weather, above 90°F (32°C)
Where time and mileage are listed, follow the
interval that occurs first.
EMISSION CONTROL SYSTEM MAINTENANCE
The scheduled emission maintenance listed in bold
type on the Maintenance Schedules, must be done at
the mileage specified to assure the continued proper
functioning of the emission control system. These,
and all other maintenance services included in this
manual, should be done to provide the best vehicle
performance and reliability. More frequent mainte­
nance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
UNSCHEDULED INSPECTION
At Each Stop For Fuel
• Check engine oil level and add as required.
• Check windshield washer solvent and add as
required.
page
M E D I U M D U T Y S C H E D U L E — B 9
U N S C H E D U L E D I N S P E C T I O N . . . . . . . 8
Once A Month
© Check tire pressure and look for unusual wear
or damage.
• Inspect battery and clean and tighten terminals
as required.
• Check fluid levels of coolant reservoir, brake
master cylinder, power steering, and transmission
and add as needed.
• Check all lights and all other electrical Items for
correct operation.
At Each Oil Change
• Inspect exhaust system.
• Inspect brake hoses.
• Rotate the tires at each oil change Interval
shown on Schedule—A (7,500 Miles) or every other
Interval shown on Schedule—B (6,000 Miles).
• Check engine coolant level, hoses, and clamps.
• Lubricate steering linkage.
MEDIUM DUTY SCHEDULE—A
6,000 miles (10 000 km) or at 6 months
• Replace engine oil and filter.
12,000 Miles (19 000 km) or at 12 months
• Replace engine oil and filter.
18,000 Miles (29 000 km) or at 18 months
® Replace engine oil and filter.
• Inspect brake linings.
24,000 Miles (38 000 km) or at 24 months
• Replace engine oil and filter.
• Drain and refill automatic transmission fluid.
Replace filter and adjust bands.
• Inspect front wheel bearings. Clean and repack,
if required (4x2).
30,000 Miles (48 000 km) or at 30 months
© Replace engine oil and filter.
• Replace engine air cleaner element.
• Replace spark plugs.