Installation; Receiving And Storage - Harsco Industrial C1500H Installation & Owner's Manual

2.5.5 Pressure Hazards
General Warning
2.5.6 Slip, Fall Hazards
General Warning

3 INSTALLATION

gas supplier.
3.1 R S
ECEIVING AND TORAGE
3.1.1 Initial Inspection
Upon receiving the boiler, inspect it for signs of shipping damage. Since some damage may be hidden, unpack
the boiler, open the front, and side doors and inspect the boiler. Verify that the total number of pieces shown on the
packing slip agrees with those actually received.
NOTICE! Note any damage, suspected potential damage, or shortage of materials on the freight bill and immediately
notify the carrier. File all claims for shortage or damage with the carrier. Claims for hidden damages must be filed
with your carrier within 7 days. The boiler carton is equipped with a "Tip (N) Tell". If "Tip (N) Tell" arrow point is blue,
that indicates that the package has been on its side or tipped over in transit.
3.1.2 Storage Prior to Installation
If the boiler is not installed immediately, it must be stored in a location adequately protected from the weather,
preferably indoors. If this is not possible, then it should remain in the shipping container and be covered by a
tarpaulin or other waterproof covering.
NOTICE! Controls and other equipment that are damaged or fail due to weather exposure are not covered by
warranty.

Pressure hazard! Hot fluids. Install isolation valves on boiler water inlet and outlet.
Make sure isolation valves are closed before servicing boiler.

Pressure hazard! Hot fluids. Annually test safety relief valve for proper operation. Do
not operate boiler with faulty relief valve.

Tripping hazard! Do not install piping on floor surfaces. Maintain clear path around
boiler.

Slip and fall hazard! Use drip pan to catch water while draining the boiler. Maintain dry
floor surfaces.

Slip and fall hazard! Do not locate intake or exhaust terminations directly above a
walkway; dripping of condensation can cause icing of the walking surface. (see section
3.5)

Fall hazard! Do not stand on boiler.
Installation and service must be performed by a qualified installer, service agency, or
11
®
MACH Gas Fired Boiler