Appendix; Appendix 1 - Mach ® Boiler Fire Test Report - Harsco Industrial C1500H Installation & Owner's Manual

8 APPENDIX

8.1 A 1 – MACH
PPENDIX
Boiler
Installation:
State:
Installer Name:
Fuel:
Outdoor Temperature Sensor Connected
1. Factory Fire-Test : (copy from boiler label)
High
Inlet Gas
Oxygen (O2)
Carbon Dioxide (CO2)
Carbon Monoxide (CO)
Gross Stack Temp.
2. Water Inlet temperature:
3. Flow through boiler:
4. Operating Temperature Setpoint:
5. Stack Pressure (measured where stack exits boiler):
6. Approximate stack lengths:
7. Incoming Electrical Power
8. Sytem Water pH level
9. Comments:
Performed by:
®
B F T R
OILER IRE EST
MACH
FIRE-TEST REPORT
Mode
Zip:
Natural Gas Propane
Yes:
Low
"w.c. "w.c.
% %
% %
ppm ppm
° F ° F
° F Water Outlet temperature:
GPM
° F (from internal OR external control
"w.c. (High)
Ft. Horizontal Ft. Vertical
Volts a.c. Less than 1 volt between neutral and ground
(Print Name)
Please return a copy to Harsco Industrial, Patterson-Kelley, ATTN: Boiler Technical Service
Harsco Industrial, Patterson-Kelley • 100 Burson Street • E. Stroudsburg, PA 18301
Phone: (570) 476-7261 • Fax: (570) 476-7247 • www.harscopk.com
EPORT
®
BOILER
City:
Contact
Type of Installation:
No:
Field Fire-Test: DATE:
High
Inlet Gas "w.c.
Oxygen (O2) %
Carbon Dioxide (CO2) %
Carbon Monoxide (CO) ppm
Nox ppm
Gross Stack Temp. ° F
Combustion Air Temp. ° F
Stack Press.(exhaust) "w.c.
Main Flame Signal Yes/No
Efficiency %
Comb. Air Pres. (intake) "w.c.
° F
)
"w.c. (Low)
Flue Pipe Diameter
81
®
MACH
Dat
Phone:
(Hotel, School, etc.)
Low
"w.c.
%
%
ppm
ppm
° F
° F
"w.c.
Yes/No
%
"w.c.
Gas Fired Boiler