Winterizing Your Spa; The Spa Cabinet - Emerald Spa Lite Leader Owner's Manual

Winterizing Your Spa

Caution:
Do not use Automobile
type radiator antifreeze.
Note:
It is possible to use the air
blower (if equipped) to purge
the air lines. Ask your dealer
for assistance if you want
to use this procedure.
Note:
If you cannot drain all the
water, especially from the blower
air injector lines, add an inhibited
propylene glycol type antifreeze
to any remaining water. Propylene
Alcohol can be purchased most
commonly in a store with a
Recreational Vehicle section.

The Spa Cabinet

Note:
Do not apply varnish,
shellac, or surface sealants
to the wood. They
tend to react with
chemicals in the wood
and the UV rays of
the sun to cause yellowing,
peeling, and flaking.
The following procedure should be followed if you choose to deactivate your spa for the winter months.
1. Drain all water from spa using drain hose.
2. Unplug the pump power cords from the control outputs.
3. Press the blower keypad and run blower until all air lines are dry.
4. Vacuum out each jet and air injector with a shop vac.
5. Remove any remaining water in the spa with a sponge or cloth.
6. Turn power off at main power supply panel.
7. Disconnect all plumbing from power pack at unions. Open T-valves to allow water to drain.
8. Open drain valve.
9. Connected to the manifold is a hose that allows drainage of the manifold. Connect a hose to the
spigot and drain the manifold.
10. Clean spa as instructed in maintenance section.
11. Use a locking spa cover to keep water out and prevent unauthorized use.
The red cedar cabinet of your spa is protected with a wood sealer. It is normal for the cabinet to take on a
weathered appearance with time and exposure to the elements.
Protect and revive the wood surface with a light sanding and the application of a wood preservative or
tongue oil. Since Emerald uses only decay-resistant woods in its spa construction, you may choose to allow
your cabinet to age with time and weather.
Durabilt Cabinet
If you have purchased an optional Durabilt cabinet, know that the outer surface of the Durabilt Cabinet is
made completely of a synthetic material. To clean, take a dampened rag with mild dish soap and wash the
outside panels.
49
Maintaining Your Spa