Westerbeke 7.0 KW BGC -60Hz Technical Manual page 129

DC CONTROL CIRCUIT WIRING DIAGRAM #38028
Page 2 of 2
SCHEMATIC DIAGRAM
I 2 VDC BATTERY
+
dill
STAIn"ER
-l-
~
START R SOLENOIO
r
I
I
1
CIRCUIT BREAKER
L
I
20
AMP
__ J
STOP
SWITCH
FUSE
8AIoIP
NOTE 5
I
TBI-I
I
L - _ _
BA HERY CHARGER
CHOKE SOLENOIO
CARB. SOLE NOlO
FUE PUMP
BALLAST
COIL
OISTRlBUTOR
+
RESISTOR
+
OIL PRESSURE
I
SWITCH
J,t
EXHAUST TEMP
t SWITCH
15AMP
r
,--- - - " ' 1 " - - - - - -
1-------
¥
WATER TEMP.
I I
I
I
1
SWITCH
"" KI,87 r'OIL PRESSURE
:,1,1 ~~g~RTEMP.
l
ISENDER
(OPTIONAL) J (OPTIONAL)
NOTE 3
NOTE 3
IT3
TI
T21
ON SWITCH
OVERSPEEO SWITCH
1
+
"""I
I
HOUR IoIETER
I
START SWITCH
____ I
0
~
T l
86
85
KI
QUICK CONNECTS
nt.51
-
TBI~ TBI 2 B 3
I
-------------------~
REMOTE PANEL CONNECTIONS
RESPONSIBILITY FOR SAFETY REGULATIONS
I. BATTERY CHARGER CAUSES A 9ma DRAIN AND OVERSPEED MODULE CAUSES A 15ma DRAIN WHEN GENERATOR
IS NOT OPERATING. THEREFORE. WHEN LEAVING BOAT FOR AN EXTENDED PERICXl. DISCONNECT THE BATTERY.
2. WESTERBEKE GASOLINE MARINE GENERATORS, AS SHIPPED FROM THE FACTORY AND EXCLUSIVE 0- OPTIONAL
REMOTE INSTRUMENT OR CONTROL PANELS,COMPLY WITH U.S. COAST GUARD 33CFR-183. ACCESSORY
INSTRUMENT AND CONTROL PANELS DO NOT NECESSARILY SO COMPLY AND ARE INTENDED TO BE INSTALLED
ABOVE DECK AND "ISOLATED FROM GASOLINE SOURCES" IN ACCORDANCE WITH 33CFR-183.410(bl.
IT IS THE RESPONSIBILITY OF THE BOAT MANUFACTURER TO INSURE THAT THE INSTALLATION OF THESE
GENERATORS AND OPTIONALLY. THEIR REMOTE INSTRUMENT OR CONTROL PANELS,COMPLY WITH 33CFR-I83.
3. SENDERS SUPPLIED WITH OPTIONAL INSTRUMENT PJl\NEL.
4. MINIMUM RECOMMENDED WIRE GAUGE TO REMOTE PANEL IS
No.
14 AWG.
5. REMOVE JUMPER BETWEEN TBI-I AND TBI-2 WHEN USING REMOTE PANEL.
125
Westerbeke Generators