Table Of Contents - Carrier 58MVP Installation, Start-Up, And Operating Instructions Manual

Table of Contents

Table Of Contents1
Multipose Orientations1
Safety Considerations2
Dimensional Drawing3
Installation4
Minimum Inches Clearances To Combustible Construction4
Codes And Standards5
Return-Air Temperature5
Installation In A Garage5
Electrostatic Discharge (Esd) Precautions5
Upflow Applications6
Condensate Trap6
Condensate Trap Tubing (Factory-Shipped Orientation)7
Condensate Trap Location (Alternate Upflow Orientation)7
Condensate Trap Tubing (Alternate Upflow Orientation)8
Pressure Switch Tubing8
Condensate Trap Location8
Condensate Trap Tubing8
Inducer Housing Drain Tube9
Condensate Trap Freeze Protection10
Horizontal Left (Supply-Air Discharge) Application10
Horizontal Right (Supply-Air Discharge) Application11
Attic Location And Working Platform12
Horizontal Right Tube Configuration12
Location13
Low-Heat Only Installation14
Proper Condensate Drainage14
Prohibit Installation On Back14
Levelling Legs15
Installation In Upflow Or Downflow Applications15
Hazardous Locations15
Opening Dimensions16
Installation In Horizontal Applications17
Air Ducts18
Filter Arrangement18
Ductwork Acoustical Treatment18
Supply Air Connections18
Bottom Closure Panel19
Gas Piping19
Filter Information19
Electrical Connections20
Maximum Capacity Of Pipe20
Removing Bottom Closure Panel20
Typical Gas Pipe Arrangement20
Electrical Data21
Heating And Cooling Application Wiring Diagram21
Disconnect Switch And Furnace21
Continuous Fan (Cf) Setup Switches22
Setup Switches (Sw1)22
Relocating J-Box22
Accessories23
Removal Of Existing Furnaces From Common Vent Systems23
Combustion-Air And Vent Piping23
Direct Venting23
Wiring Diagram24
Schematic Diagram24
Approved Combustion-Air And Vent Pipe, Fitting And Cement Materials25
Control Center Diagram25
Direct Vent Termination Clearance26
Combustion-Air And Vent Pipe Connections27
Maximum Allowable Pipe Length28
Combustion-Air And Vent Pipe Diameter30
Combustion-Air And Vent Pipe Attachment30
Short Vent (5 To 8 Ft) System30
Combustion-Air Intake Housing Plug Fitting31
Extended Exposed Sidewall Pipes32
Two-Pipe Termination Kit32
Concentric Vent And Combustion-Air Termination Kit Installation32
Roof Termination33
Sidewall Termination33
Rooftop Termination34
Condensate Drain35
Multiventing And Vent Terminations35
Start-Up, Adjustment And Safety Check36
Select Setup Switch Positions36
Condensate Drain Protection36
Air Conditioning (A/C) Setup Switches36
A/C Or Cf Airflow Selection Chart37
Prime Condensate Trap With Water38
Purge Gas Lines38
Furnace Setup Switch Description38
Blower Off Delay Setup Switch Position38
Inducer Prepurge Period39
Igniter Warm-Up39
Trial-For-Ignition Sequence39
Flame-Proving39
Two-Stage Thermostat And Two-Stage Heating40
Cooling Mode40
Single-Speed Cooling40
Single-Stage Thermostat And Two-Speed Cooling (Adaptive Mode)40
Thermidstat Mode41
Super-Dehumidify Mode41
Continuous Blower Mode41
Two-Stage Thermostat And Two-Speed Cooling41
Heat Pump42
Component Test42
Set Gas Input Rate42
Continuous Blower Speed Selection From Thermostat42
Orifice Size And Manifold Pressures For Gas Input Rate46
Altutude Derate Multiplier For Usa48
Redundant Automatic Gas Valve48
Burner Orifice48
Burner Frame48
Set Temperature Rise49
Gas Rate Cu Ft/Hr49
Check Safety Controls50
Set Thermostat Heat Anticipator50
Check Primary Limit Control50
Check Pressure Switches50
Checklist51
Load Calculation52