Fuel Valve; Inline Fuel Filter - E-TON CXL-150 Owner's Manual

Use unleaded automobile gasoline with an
octane level of 89 or higher.
Your ATV is equipped with a fuel gauge
located in the instrument cluster between the
handlebars.
NEVER REFUEL YOUR ATV when the
Wait 30 minutes after turning
engine is HOT.
off the unit before refueling. Spilling fuel on a
HOT engine could cause a fire. Wipe up any
fuel spills before re-starting.

Fuel Valve

The unit is equipped with a vacuum controlled
fuel valve. The fuel supply is automatically shut
off when the engine is stopped.
The fuel will automatically begin to flow when
the engine is turned over.
To test the fuel valve remove the fuel line from
the carburetor and place the end in a container
to catch the fuel. Insure that your tank has fuel
and press the starter button. Fuel should flow
into the container from the fuel line.
ALWAYS CHECK YOUR Fuel level before
you start riding your
Remember: You can drive further in one hour
on your ATV than you can walk in one day.

Inline Fuel Filter

Copyright ©2008-2009 ETON America, all rights reserved.
ATV.
Your ATV is equipped with an inline fuel filter
to prevent dirt and debris from entering the
carburetor and engine.
Check the filter for dirt or damage before each
ride and at each refueling. Replace the filter if
dirty or damaged.
DO NOT operate the unit with out a fuel filter.
Doing so can cause damage to the carburetor
and engine.
The filter should be replaced every 600 hours
of operation and at the start of each season.
To replace the filter, carefully compress the
wire clamp rings until the clamp is free of the
fuel line. Slide each clamp away from the filter
about ¾".
Remove the filter from the fuel line by holding
the line and pulling the filter. Install the new
filter by inserting the filter into the fuel line and
returning the clamps to the original position.
Start the engine and check for leaks. Inspect
the fuel lines for cuts, abrasions and
deterioration. Replace fuel lines as needed.
start or operate the engine if the fuel
DO NOT
filter or lines are leaking. Leaking fuel can
cause a fire.
Page 10