Table of Contents
Advertisement
START-UP CHECKLIST — CARRIER 39M GAS-FIRED FURNACE RACK ASSEMBLY
NOTE: To avoid injury to personnel and damage to equipment or
property when completing the procedures listed in this start-up
checklist, use good judgment, follow safe practices, and adhere to
the safety considerations/information as outlined in preceding sec-
tions of this Installation Instruction document.
I. PRELIMINARY INFORMATION
FURNACE SERIAL NO(S). __________________________________
CARRIER MODEL NO. _____________________________________
SERIAL NO. ______________________________________________
START-UP DATE __________________________________________
START-UP CONTRACTOR __________________________________
TECHNICIAN NAME _______________________________________
PHONE _________________________________________________
TYPE OF GAS ___________________________________________
GAS PRESSURE AT INLET (BURNERS OFF) ____________________________________________________________ in. wg
SUPPLY VOLTAGE AT JUNCTION BOX ___________________________________________________________________ vac
II. OPERATING SET-UP
OPERATING SET-UP DATA
Gas Press. at Supply Inlet
Gas Input Rate
CO
in Flue Gas
2
CO in Flue Gas
Flue Gas Temp at Discharge
Temperature Rise
III. OPERATION CHECKLIST
All gas lines and connections checked for leaks (Pg 196)
Adequate combustion air (Pg 196)
Condensate drain lines installed (Pg 194)
Any system deficiencies noted
DESCRIBE:
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________
SIGNATURE:
© 2022 Carrier
Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.
Catalog No. 04-53390026-01
LOW FIRE (0v DC)
___________in. wg
____________Btuh
Measurements at Common Header Discharge
_______________%
_____________ppm
______________°F
______________°F
Printed in U.S.A.
Form 39M-23SI Rev. C
SINGLE UNIT
HIGH FIRE (10v DC)
___________in. wg
____________Btuh
_______________%
_____________ppm
______________°F
______________°F
_______________________________
DATE:
Pg CL-6
2 RACKED FURNACES IN
SERIES — SECONDARY
SYSTEM
HIGH FIRE (10v DC)
___________in. wg
____________Btuh
_______________%
_____________ppm
______________°F
______________°F
(Y/N) _____
(Y/N) _____
(Y/N) _____
(Y/N) _____
6-22
Replaces: 39M-20SI
Advertisement
Table of Contents
