Table of Contents
Advertisement
START-UP CHECKLIST — CARRIER 39M GAS-FIRED DUCT FURNACE
NOTE: To avoid injury to personnel and damage to equipment or
property when completing the procedures listed in this start-up
checklist, use good judgment, follow safe practices, and adhere to
the safety considerations/information as outlined in preceding sec-
tions of this Installation Instruction document.
I. PRELIMINARY INFORMATION
FURNACE SERIAL NO(S) __________________________________________________
CARRIER MODEL NO._____________________________________________________
SERIAL NO. _____________________________________________________________
START-UP DATE _________________________________________________________
START-UP CONTRACTOR _________________________________________________
TECHNICIAN NAME ______________________________________________________
PHONE ________________________________________________________________
TYPE OF GAS ___________________________________________________________
GAS PRESSURE AT INLET (BURNERS OFF)_____________________________________________________________ in. wg
SUPPLY VOLTAGE AT JUNCTION BOX __________________________________________________________________ vac
II. OPERATING SET-UP
OPERATING SET-UP DATA
Gas Press. at Train Inlet
Gas Press. at Burner Manifold
Gas Input Rate
CO
in Flue Gas
2
CO in Flue Gas
Flue Gas Temp at Discharge
Temperature Rise
III. OPERATION CHECKLIST
All gas lines and connections checked for leaks (Pg 191)
Adequate combustion air (Pg 188)
Condensate drain lines installed (Pg 188)
Any system deficiencies noted
DESCRIBE:
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________
SIGNATURE:
SINGLE UNIT
LOW FIRE (0V DC)
HIGH FIRE (10V DC)
___________in. wg
___________in. wg
____________Btuh
_______________%
_______________%
_____________ppm
_____________ppm
______________°F
______________°F
CL-5
2 UNITS IN SERIES —
SECONDARY HEATER
HIGH FIRE (10V DC)
___________in. wg
___________in. wg
____________Btuh
______________°F
______________°F
_______________________________
DATE:
___________in. wg
___________in. wg
____________Btuh
_______________%
_____________ppm
______________°F
______________°F
(Y/N) _____
(Y/N) _____
(Y/N) _____
(Y/N) _____
Advertisement
Table of Contents
