Removing The Seat; Mounting The Seat; Dismounting The Fuel Tank - KTM 250 XCF-W USA 2010 Owner's Manual

MAINTENANCE WORK ON CHASSIS AND ENGINE

Removing the seat

11.91

Mounting the seat

11.92

Dismounting the fuel tank

11.93
Danger
Fire hazard Fuel can highly flammable.
–
Never fill up the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no
fuel is spilt, especially on hot vehicle components. Clean up spilt fuel immediately.
–
Fuel in the fuel tank expands when warm and can escape if the tank is overfilled. See specifications on filling up with fuel.
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
–
Avoid contact between fuel and skin, eyes and clothing. Do not inhale fuel vapors. If fuel gets into your eyes, rinse immedi-
ately with water and contact a doctor. Wash affected skin areas immediately with soap and water. If fuel is swallowed, con-
tact a doctor immediately. Change clothing that has come into contact with fuel. Store fuel in a suitable canister according
to regulations and keep it out of the reach of children.
–
Refit the fuse.
Fuse (58011109110)
Info
A reserve fuse
Replace a burned-out fuse
If the new fuse burns out, contact an authorized KTM workshop.
–
Replace the protection cover.
400273-10
–
Install the air filter box lid. (
–
Remove screw
above.
500080-10
–
Hook in the front of the seat at the collar sleeve of the fuel tank, lower it at the rear
and simultaneously push it forward.
–
Make sure that the seat is correctly locked in.
–
Mount and tighten the screw of the seat fixing.
Guideline
Remaining screws, chassis
600674-01
x
–
Remove the seat. (
–
Turn handle
–
Pull off the fuel hose.
Info
Remaining fuel may flow out of the fuel hose.
–
Remove screws
(250 EXC-F EU)
–
Hang the horn and horn bracket to one side.
600678-10
is located in the starter relay.

only by an equivalent fuse.

p. 76)
. Lift up the seat at the rear, pull it back and then remove from

p. 71)
of the fuel tap to the OFF position. (Figure 500137-10

with the collar sleeve.

M6 10 Nm (7.4 lbf ft)
71
p. 20)