Vehicle - Hisun HS 250UTV Owner's/Operator's Manual

From beginning starter
does not function,and
lights soon become dim
When viewed from the
top of plates, look
whitish.
* Refillable type battery
only
Recharging is impossible.
Terminals are severely
corroded and heat up.
Battery electrolyte level
drops rapidly.
* Refillable type battery
only

If you have any questions, consult your local dealer.

The factory installed battery is non-refillable type.
VEHICLE TROUBLESHOOTING
Trouble
Gearshift does not
move freely
Introduction HS 200UTV/HS 250UTV
been recharged.

P o o r t e r m i n a l
c o n n e c t i o n

Battery life expired

Insufficient
charging

Battery was used
with an insufficient
amount
electrolyte.

Battery was used
with too
without recharging.

Battery life expired.

Poor terminal
connection

There is a crack or
pin holes in the
electrolytic cells.

Charging system
trouble.
Cause

High idling speed of engine

Clean the terminal
and
securely.

Replace
battery

Charge
Insufficiently

Add distilled water
and charge
of
battery.

Charge
much
Insufficiently

Replace battery.

Clean the terminal
and
securely.

Replace battery.

Consult your local
dealer.



1-57

Keep the terminal
clean and tight.
tighten
Apply grease and
treat with anti-corrosive.
new

Battery
battery
serviced
before initial use

Regularly check the
the
electrolyte level.

battery Charge
properly

Keep the terminal
clean and tight.
tighten Apply grease
treat with
corrosives.
Countermeasure
Replace throttle cable;
Replace throttle petal
Replace the throttle
must be
properly
battery
and
anti-