Transporting The Machine; Maintaining The Lithium Ion Battery Pack; Caring For The Battery Pack - Toro Greensmaster eFlex 2120 Operator's Manual

•
Do not disassemble the charger. Take the charger
to an authorized Toro distributor when service or
repair is required.
•
Unplug the power cord from the outlet before
starting any maintenance or cleaning to reduce
risk of electric shock.
•
Maintain or replace safety and instruction labels
as needed.
•
Do not operate the charger with a damaged
cord or plug. Replace a damaged cord or plug
immediately.
•
If the charger has received an impact, been
dropped, or otherwise damaged, do not use it;
take it to an authorized Toro distributor.

Transporting the Machine

After mowing, transport the machine away from the
job site; refer to Transporting the Machine Using
Transport Wheels (page 22)
Machine Using a Trailer (page
Maintaining the Lithium Ion
Battery Pack
WARNING
The battery pack contains high voltage, which
could burn or electrocute you.
• Do not attempt to open the battery pack.
• Do not place anything in the connector
of the battery pack other than the wire
harness connector that came with the
product.
• Use extreme care when handling a battery
pack with a cracked case.
• Use only the charger designed for the
battery pack.
Transporting the Battery Pack
The US Department of Transportation and
international transportation authorities require that
lithium ion batteries be transported using special
packaging and only be transported by carriers certified
to haul them. In the US, you are allowed to transport
the battery when it is installed on the machine as
battery powered equipment, with some regulatory
requirements. Contact the US Department of
Transportation or the appropriate government body in
your country for detailed regulations on transportation
of your eFlex or eFlex battery.
or Transporting the
22).
For detailed information on shipping the battery pack,
refer to the Installation Instructions included with the
Battery Shipping Kit. These instructions are available
on www.Toro.com.

Caring for the Battery Pack

The lithium-ion-battery holds a sufficient charge to
perform intended work during its life span. As time
goes by, the total amount of work the battery is able
to complete on a single charge gradually diminishes.
The following table lists the approximate expected
work that the machine should be capable of over the
first 4 years of use:
Year
1
2
3
4
Note:
Your results may vary depending on the
distance you need to transport the machine, the
contact setting of the bedknife, and other factors as
discussed in this section.
To achieve maximum life and use from your battery,
apply the following care guidelines:
•
Do not open the battery pack. There are no user
serviceable parts inside. If you open the pack you
will void your warranty. The pack is protected by
tamper-alerting devices.
•
Store/park the machine in a clean, dry garage or
storage area, away from direct sunlight and
heat sources. Do not store it in a location where
the temperature drops below -30°C (-22°F) or
rises above 60°C (140°F). Temperatures outside
of this range will damage your battery. High
temperatures during storage, especially at a high
state of charge, reduces the life of the batteries.
•
When storing for more than 10 days, ensure that
the machine is in a cool location, out of sunlight,
and at least 50% charged.
•
If you are mowing in hot conditions or in sunlight,
the battery may overheat. If this happens,
a high-temperature alert will appear on the
InfoCenter LCD display. In this condition, the
machine no longer operates with the reel engaged
and the machine slows down.
Immediately drive the machine to a cool location
out of the sun, turn off the machine, and allow the
battery to cool fully before resuming operation.
•
Keep the battery pack cover clean. The white
color reflects sunlight and slows the heat buildup
in the battery pack. A dirty cover increases the
29
Area Cut Per Full Charge
3,809 m 2 (41,000 ft 2 )
3,623 m 2 (39,000 ft 2 )
3,252 m 2 (35,000 ft 2 )
3,066 m 2 (33,000 ft 2 )