Braun VISTA Series Installation & Service Manual page 8

Item Qty.
1 Pump Module (complete), 12 Volt, Rear
1 1 Pump Assembly (M-268-0105) 12V-190 / S. 02 - with Reservoir and Backup Pump)
2 1 Fitting, 7/16-20 O-Ring Male / 7/16-20 JIC 37° Male
3 1 Elbow, 7/16-20 JIC 37° Female Swivel (1) / 7/16-20 JIC 37° Male (2)
4 1 Switch, Pressure
5 1 Clamp, Hose - Solenoid Mounting
See Control Box Assembly and Harness Options ✘ See note below
6 1
See Control Box Assembly and Harness Options ✘ See note below
7 1
Control Box, Bracket-mount (Items 9, 10 and 11) ✘ See note below
8 1
Control Box (only) ✘ See note below
9 1
Clip, Bracket-mount ✘ See note below
10 1
Screw, #6-20 x 1-1/4", Pan Head, Phillips ✘ See note below
11 3
Face Plate and Switch Assembly ✘ See note below
12 1
Face Plate ✘ See note below
13 1
Switch, S.P.D.T., Rocker (Unfold/Fold) - Orange ✘ See note below
14 1
Switch, S.P.D.T., Rocker (Down/Up) - Red ✘ See note below
15 1
Screw, #6-20 x 3/4", Pan Head, Phillips ✘ See note below
16 4
Strain Relief (SR 7W-2) ✘ See note below (7A, 7B and 7C only)
17 1
Cover, Switch Box ✘ See note below
18 1
19 1 Power Cable, Millennium - Up Solenoid to Motor
20 1 Solenoid, 4-Post
21 1 Harness, Up/Down Solenoid
22 1 Cable, Pump Module Power Feed, #4 Gauge Red
23 1 Harness, Up Solenoid / Circuit Breaker
24 1 Circuit Breaker, 5 Amp, Manual Reset
25 1 Harness, Power / Ground
26 1 Harness, Pendant Control Cable
27 1 Harness, Main
28 1 Jumper, Interlock
29 1 Jumper, Positive or Negative Logic - Vista
30 1 Circuit Board, Seat Belt Interlock with Light
31 4 Standoff, 1/4" Long, Printed Circuit Board
32 4 Screw, #6 x 3/8", Self Tap, Flat Head
33 4 Snap Rivet, 1/8", Nylon, Black
34 1 Stud, Power Feed
Cable, Lift Power, 37' with Loom ✘ See note below
35 1
Rubber Boot, Red ✘ See note below
36 1
37 1 Harness, Power / Interlock LED - Red
38 1 Harness, Power / Interlock LED - White
39 1 Cable, Ground - 36"
40 1 Diode Assembly, Up Solenoid
41 2 Bolt, 5/16-18 x 1/2", Nylock, Hex * See note below
42 2 Bolt, 5/16-18 x 3/4", Nylock, Hex * See note below
43 2 Washer, 5/16" Flat
44 1 Plate, Backing / Mounting
45 1 Cover, Pump, 2-Piece - Back/Bottom
46 1 Diode, Green LED, Panel Mount
47 1 Recepticle, Clip On
48 1 Harness, Seat Belt, Front Pump
49 1 Pump Handle with Grip
50 1 Cover, Pump - 2-Piece - Top / Front Assembly (Includes Items 51 - 61)
51 1 Cover, Pump - 2-Piece - Top / Front
52 1 Clip, Handle - Top Cover
53 1 Washer, Nylon 1/4" I.D. x 11/16" O.D. x .030"
54 1 Clip, Handle - Bottom Cover
55 3 Pop Rivet, 1/8" - .13/.19", SD43BS
56 1 Stud, Wing Head - 1/4 Turn
57 1 Retainer, Push On
58 1 Decal, Removal Instruction - Pump Handle (Not shown - see Decal Section)
59 1 Decal, Hydraulic Pressure Switch Instruction and Warning (Not shown - see Decal Section)
60 1 Decal, Manual Hand Pump Instruction (Not shown - see Decal Section)
61 1 Decal, Pump Cover Installation / Removal (Not shown - see Decal Section)
62 1 Decal, Pressure Relief Valve Warning (Not shown - see Decal Section)
Control Box Assembly and Harness Options
Item Qty.
Control Box Assembly (with Standard Quick Disconnect Harness) ✘ See Note Below
6A 1
Control Box Assembly (with Armored Quick Disconnect Harness) ✘ See Note Below
6B 1
Control Box Assembly (with Coiled Quick Disconnect Harness) ✘ See Note Below
6C 1
Control Box Assembly (with 7' Long, 18 Ga., Quick Disconnect Harness) ✘ See Note Below (not shown)
6D 1
Harness, Standard, Quick Disconnect (without control box) ✘ See Note Below
7A 1
Harness, Armored, Quick Disconnect (without control box) ✘ See Note Below
7B 1
Harness, Coiled, Quick Disconnect (without control box) ✘ See Note Below
7C 1
Harness, 7' Long, 18 Ga., Quick Disconnect (without control box) ✘ See Note Below (not shown)
7D 1
✘ Indicates items available for replacement part purposes only. These items are not included with replacement pump
modules.
* Apply red #271 Thread Locker Loctite
present on the bolts when retrofitting an M268 pump assembly. Loctite
under part number 11522.
Page 6
Series 02 VL917IB
Series 02 VL917IB Pump Module Parts List
Description
Description
®
to the three pump mounting bolts (items 41 and 42) if a blue nylon patch is not
Supplement 29682
® is available from The Braun Corporation
Series 02 VL917IB Supplement 29682
VL917FIB VL917IB
Part No. Part No.
975F2516IBQD 975R2516IBQD
29417A12V 29417A12V
24504 24504
26579 26579
26577 26577
29663 29663
16970A 16970A
16932 16932
16933 16933
16945 16945
17909A-05 17909A-05
16931-05 16931-05
17332 17332
16942 16942
24739 24739
11352 11352
26798 26798
29049 29049
28308 28308
975-2533A 975-2533A
26082A-4 26082A-4
25809A 25809A
25736 25736
975-2530A 975-2530A
975-0531A 975-0531A
975F0532A 975-0532A
15708A 15708A
29247 29247
29557A 29557A
86739 86739
82764 82764
25759 25759
26084 26084
205-0712-37 205-0712-37
82046 82046
29546A 29546A
29559A 29559A
26161A 26161A
73906A 73906A
10012 10012
29608 29608
10063 10063
975F0501 975R0501
915F5513B 915R5513B
29545 29545
28803 28803
975-0534A NA
17206A 17206A
915R5513TA 915F5513TA
915F5513T 915R5513T
915-5517 915-5517
12690 12690
915-5518 915-5518
12954 12954
28804 28804
28805 28805
29052 29052
27154 27154
29082 29082
29051 29051
22249 22249
Part No.
900-0903AQD
900-0903AQDA
900-0903AQDC
900-5903AQD
900-0902AQD
900-0902AQDA
900-0902AQDC
900-5902AQD
Revised: May 21, 2003