Uvl series private use wheelchair lifts (38 pages)
Summary of Contents for Braun NVL Vista 03 Series
Page 1
Service Manual for: Vista Public Use Wheelchair Lifts Series DOT — Public Use Lift DOT — Public Use Lift “DOT — Public Use Lift” verifies that this platform lift meets the “public use lift” requirements of FMVSS No. 403. This lift may be installed on all vehicles appropriate for the size and weight of the lift, but must be installed on buses, school buses, and multi- purpose passenger vehicles other than motor homes with a gross...
Page 2
The warranty cards must be processed to activate the warranty. Two Braun Serial No./Series No. identification tags (shown below) are posted on the lift. One I.D. tag is posted on the opposite pump side vertical arm. A second I.D. tag is located on the opposite pump side tower.
Certification Checklist Diagnostic Procedures Use the following adjustment procedures should the lift not function as described in the certification checklist. These procedures must be followed in order for the lift to be FMVSS 403/404 compliant. • Vehicle movement is prevented unless the platform is fully stowed. 1.
Page 5
Certification Checklist Diagnostic Procedures • The inner rollstop will not raise if occupied. - Call Product Support • The outer barrier will not raise if occupied. - Call Product Support. • Verify platform lighting when lift is deployed. 1. Replace bulb(s) in the light housing. 2.
Lift Wiring Diagram Platform Lights (Option) Note: All wires 22 GA. 985-A1534NA unless otherwise noted. 6-COND WIRE CODE COLOR BLACK 985-2541NA WHITE GREEN ORANGE JUMPER #1 (CAVITY #2 TO #4) NOT USED ORANGE JUMPER #2 (CAVITY #3 TO #8) NOT USED 13 12 11 10 Lift...
LCD Lift Codes Listed below are codes that the lift controller outputs during lift operation. The codes will be displayed on an LCD screen located on the lift control board inside the pump module. See the Manual Operating Instruc- tions in the operator's manual for pump cover removal instructions.
(items 29 and 30) if a blue nylon patch is not present on the bolts when retrofitting an M268-0112 pump assembly. Loctite ® is available from The Braun Corporation under part number 11522. t Indicates items available for replacement part purposes only. These items are not included with replacement pump modules.
29 and 30) if a blue nylon patch is not present on the bolts when retrofitting an M268 pump assembly. Loctite ® available from The Braun Corporation under part number 11522-1. Note: Rear pump module shown, front pump module mirror image.
Page 18
NOTES This page intentionally left blank to provide a place for notes and references.
Page 19
"Providing Access to the World" ® Over 300 Braun Dealers Worldwide ® "Providing Access to the World" International Corporate Hdqrs: P .O. Box 310 Winamac, IN 46996 USA 1-800-THE LIFT (574) 946-6153 FAX: (574) 946-4670...
Page 20
The Braun Corporation of Winamac, Indiana, warrants that it will repair (or replace at Braun’ s sole option) any defect in material or workmanship in its wheelchair lift for five years*, providing the lift is installed, operated and maintained properly. This warranty is limited to the original purchaser and does not cover defects in the motor vehicle on which it is installed, or defects in the lift caused by a defect in any part of the motor vehicle.