Car-O-Liner CTR12000 Instruction Manual page 31

CTR12000
Coolant KF 330
Properties, handling and disposal of KF 330
CAUTION
Other types of coolant
41643, ENG - rev. 2, 2016-10
If delivery is made ex works, the welding machine is filled up with a type of
coolant that has proved to be the most suitable for welding machines.
You may order it at any time from us. Upon the order state the designation.
Cooling liquid KF 330
Delivery is made in 3-liter plastic canisters.
If the 3 liter canister is used together with 17 liter water to fill up the 20 liter
tank in CTR12000, the frost resisting degree will be around -2 C.
Transportation of the welder with filled up water tank should only be done if
the surrounding temperature is over this value.
If the surrounding temperature is under this value, risk of damages on con-
denser and c-tong is high.
The cooling liquid KF 330 may be mixed with water at any ratio. There are
no particular hazards. Nevertheless keep it away from children and avoid
any contact with beverages, food or feed stuff.
If you have accidentally swallowed some coolant, first rinse the mouth with
water and then drink a lot of water; in case of contact with the skin, thor-
oughly wash the areas concerned with water. KF 330 may cause light irrita-
tion of the eyes. We thus recommend wearing safety goggles. In case of con-
tact with the eyes, rinse them thoroughly with water for at least 10 minutes.
Use water to sweep away small quantities of spilled coolant; larger spillage
must be eliminated by using liquid-binding materials (sand, kieselguhr, uni-
versal binder, sawdust). Dispose of the coolant or contaminated material by
transporting it to a dump and observe local regulations (Waste code 07 01
04, name "Other organic solvents".
To ensure trouble-free operation and at least average service life of the weld-
ing machine, the coolant used must satisfy the following conditions:

Conductivity as low as possible (<100 mS/cm)

No metallic components

No corrosive substances (Chloride < 5 ppm/ Sulfate < 5 ppm)

Frost-resisting up to – 15°C
Car-O-Liner Group AB
31