Safety Instructions - Bennett CNG Series Installation Manual

Remote dispensers
Hide thumbs Also See for CNG Series:
Table of Contents

Advertisement

Bennett CNG Series Installation Manual
For safe installation of this equipment, read and understand all dangers, warnings, and cautionary information. Save
this safety information in a readily accessible location. Look for the following warnings throughout the manual:
Red and White "DANGER" means: If you do not follow the instructions, severe injury or death will occur.
Orange and Black "WARNING" means: If you do not follow the instructions, severe injury or death can occur.
Yellow and Black "CAUTION" means: If you do not follow the instructions, damage can occur to the dispenser.
Blue and White "IMPORTANT" means: helpful tips and other recommendations on equipment installation,
usage, and maintenance should be observed.
DANGER
FIRE, EXPLOSION, INJURY, OR DEATH WILL OCCUR IF FUEL FILTERS ARE CHANGED BY
UNTRAINED PERSONNEL. MAKE SURE, ONLY TRAINED PERSONNEL CHANGE FILTERS.
TO PREVENT INJURY TO YOU FROM VEHICLES AND ONLOOKERS, ALWAYS PLACE A
BARRIER AROUND THIS EQUIPMENT BEFORE PERFORMING SERVICE OR MAINTENANCE.
CNG IS FLAMMABLE. NO SMOKING OR OPEN FLAME.
DISCONNECT ALL POWER AND RELIEVE PRESSURE TO THIS EQUIPMENT AND ASSOCIATED
COMPRESSOR DURING INSTALLATION, SERVICE, OR ANY MAINTENANCE I.E., CHANGING
FILTERS.
WARNING
You must have training in the installation, service, or maintenance of this equipment (dispenser,
pump, console, or control box) before working on it. Maintenance repairs must be done by
authorized personnel only.
There must be a message near the dispensers that says, "Natural Gas Vehicle Fuel Cylinders shall
be periodically inspected (normally every 3 years) to ensure safe operation of the vehicle. Contact
vehicle or cylinder manufacture."
To prevent electric shock, keep the electrical parts of the dispenser dry.
Electronic components are static sensitive. Use proper static precautions (static straps) before
working on the equipment.
The shut-off ball valve for the incoming CNG Line must be closed when service or maintenance is
performed on this equipment.
Vehicle engine must be turned off while dispensing product.
No ignition source can be within 10 feet of the dispenser.
A portable fire extinguisher with a rating of no less than 20-B:C must be provided in the
dispensing area.
You must have training in the operation and programming of this dispenser before using it. READ
THE OPERATORS MANUAL.
Make sure this equipment is correctly grounded. Failure to do will cause injury or damage
equipment or improper operation. Improper grounding voids the warranty.
When anchoring the dispenser, always level the dispenser with shims before bolting to the island.
DO NOT shim the middle of base rails to bolt down the dispenser.
If the breakaway is not provided then one must be installed that will disengage at 150lbs.

Safety Instructions

PELIGRO
ADVERTENCIA
iii
Safety Instructions
DANGER
MISE EN GARDE

Advertisement

Table of Contents
loading

Table of Contents