Advertisement
SERVICE MANUAL
The model DUKE has three different settings (prudential, stand-
ard, active).
There are three lengths of rear wheel plate, each of which gives
a different setting.
Thus, you can adjust the setting by changing the rear wheel
plate.
You can also change the point of balance by moving the
backrest from point 1 (default position) to point 2 (1.5 cm more
active) or the other way round.
See adjustment sheet "seat depth".
This way, however, the seat depth is affected, too.
Changing the rear wheel plate.
Remove the bolts A and B of the rear wheel plates that are fixed
to the adjustment post.
Remove the rear wheel plates from the posts.
Now, the rear axle C is still fixed to the rear part of the wheel
plates.
The pin D may remain within the front or the rear part of the
wheel plate, or it may come off.
Loosen the bolt E and slide the rear axle off the wheel plate.
Insert the rear axle C into the rear side of the new wheel plate
until it leans off 12 mm.
A point of reference may be the position of the pin F, in fact, it
should be half covered by the wheel plate where indicated in the
picture.
Assemble the front side of the wheel plate with the pin D, insert
the two bolts A and screw them until leaving 2-3 mm gap be-
tween the two parts of the wheel plate.
Assemble the other wheel plate in the same way.
Insert the two wheel plates of the rear unit into the posts to the
desired height.
Now proceed following the instructions of the adjustment sheet
"rear height".
Adjust the convergence (if cambered wheels), the brakes, and
the fork angle and, if necessary, adapt the side guards.
Note: over the inner side of the
two parts of the wheel plate, it is
recommended to stick a film to
further improve the grip on the
It is advisable to spread a drop of mild lock thread
glue on the on the grab screws A and B.
REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com
SETTING (point of balance)
1
2
1
Active105
Standard 90
Prudential
C
D
F
2
75
A
C
2-3 mm
Service Manual DUKE 9
B
E
A
E
A
Advertisement
