Controls Valves And Switches - 3M MATIC A80F Instructions And Parts List

11 - SET UP AND ADJUSTMENTS (continued)
Box
4
Height
Adjustment
Box Width
Adjustment
5
Main Air
Pressure
6
Gauge
2
Main Air
On/Off Valve /
Pressure Regulator /
Filter
Figure 11-4 – Controls, Valves and Switches
11.5 Controls, Valves, and Switches
(Figure 11-4)
1 Electrical "On/Off" Switch
The box drive belts are turned on and off (off
button is red) with the electrical switch on the
side of the machine guard at the infeed end.
Note – The case sealer has a circuit
breaker located in the electrical enclosure
on the lower right side of the machine
frame. If circuit becomes overloaded and
circuit breaker trips, unplug the machine
electrical cord and determine cause of
overload. After two minutes, remove the
electrical control box cover and reset the
circuit breaker by pressing the "Reset" but-
ton and then the "Start" button on the circuit
breaker. Replace the control box cover,
plug machine electrical cord into outlet and
restart machine by pressing green "On"
button.
a80f-NA
7
Kicker
Adjustment
1
Electrical
On/Off Switch
2 Main Air "On/Off" Valve/Pressure
Regulator/Filter – Figure 11-5
This set of pneumatic components controls,
regulates and fi lters plant air supply to the two
separate control circuits of the case sealer.
"On/Off" Valve –
"On" turn to "1" – "2"
"Off" turn to "2" – "3" .
Note – Turning air supply "Off" automatically
bleeds air pressure from the case sealer air
circuits.
Always turn the air "Off" when machine is not in use,
when servicing the machine, or when connecting or
disconnecting air supply line.
Note – The air valve has provisions for lockout/
tagout according to plant regulations.
Pressure Regulator regulates main air pressure
to the machine to adjust pressure, pull knob up and
turn – push down to lock setting.
Filter removes dirt and moisture from plant air
before it enters the case sealer pneumatic circuits.
If water collects in bottom of bowl, lift up on the valve
on the bottom of bowl to drain.
27
E-Stop
3
Switch
Kicker
8
Paddle
Switch
2010 March