Air Motor - WAGNER EvoMotion 40-15 Original Operating Manual

VERSION 12/2015
OPERATING MANUAL
13.3

AIR MOTOR

Incorrect maintenance/repair!
Danger to life and equipment damage.
Air motor spare parts list EM M80
1 1 U3B08018060
2 1
3 2
4 1
5 1
6 1
7 2
8 1
9 1
10 1
11 1
12 1
13 2
14 1
15 1
16 1
17 1
18 1
19 1
20 2
21 1
= Wearing parts
= Included in service set.
= Not part of the standard equipment but available as an accessory.
ORDER NUMBER DOC2333558
DANGER
Only a WAGNER service center or a suitably trained person may
carry out repairs and replace parts.
Only repair and replace parts that are listed in the "Spare parts"
chapter and that are assigned to the unit.
Before all work on the device and in the event of work
interruptions:
- Relieve pressure from spray guns and devices.
- Secure spray guns against actuation.
- Switch off the energy/compressed air supply.
- Disconnect the control unit from the mains.
Observe the operating and service manual for all work.
Order No. Designation
Air motor EM M80
F132.91C Motor fl ange, upper, M50 EM
L108.06 O-ring
D608.81 Cylinder motor
3055157 Hexagon nut with clamp
9920106 Washer
G903.06 Steamer
L413.06 Gasket DE 80
A164.01 Motor piston
L802.08 Sliding ring
L110.06 O-ring
D404.12 Piston rod, M80 EM
L109.06 O-ring
A408.12 Air tube, M80 EM
T616.00C Motor fl ange, complete M80 EM, at bottom
P498.00KNE Reversing valve ISO N/1 (spare parts list see
Chapter 11.3.1.)
367258 Grounding, complete
L403.06 Rod seal
2339340 Sensor below, M80
K606.02 Lock washer for shaft
A160.01A Washer
58