Henny Penny Evolution Elite EEG-16 Series Technical Manual page 14

Problem
Oil will not
drain from
vat.
Filter motor
runs but
pumps oil
slowly.
Bubbles in
oil during
entire filter-
ing
process.
Filter motor
will not run.
2
Cause
Improper filtering. Refer to filtering procedures.
Improper rinsing after Clean and rinse vat and then dry thoroughly.
cleaning the vat.
Drain valve clogged Open valve, force cleaning brush through drain.
with crumbs.
Drain trough clogged. Remove right side panel and remove plug from end
of trough, clean trough.
Filter line connections Tighten all filter line connections.
loose.
Filter paper or pad Change filter paper or pad.
clogged.
Filter not reassembled Refer to assembly instructions on inside door.
properly.
Filter pan not com- Make sure filter pan return line is pushed completely
pletely engaged. into the receiver on the fryer.
Filter pan clogged. Clean pan and change paper or pad.
Damaged O-ring on fil- Replace O-ring.
ter line receiver on
fryer.
Thermal reset button Allow motor to cool, then, using a screwdriver, press
on the rear of the hard against the button until it clicks.
pump motor is tripped.
•
Correction
T T o o p p r r e e v v e e n n t t b b u u r r n n s s c c a a u u s s e e d d b b y y s s p p l l a a s s h h i i n n g g
s s h h o o r r t t e e n n i i n n g g , , t t u u r r n n t t h h e e u u n n i i t t ' ' s s p p o o w w e e r r s s w w i i t t c c h h t t o o t t h h e e
O O F F F F p p o o s s i i t t i i o o n n b b e e f f o o r r e e r r e e s s e e t t t t i i n n g g t t h h e e f f i i l l t t e e r r p p u u m m p p
m m o o t t o o r r ' ' s s m m a a n n u u a a l l r r e e s s e e t t p p r r o o t t e e c c t t i i o o n n d d e e v v i i c c e e . .