Indicator Lights - Broaster VF3iXP Installation & Operation Manual

INDICATOR LIGHTS

The series of indicator lights on the Display Panel check for specific conditions that make the
VF-2 fryer safe to operate. The unit will not start or continue a cook cycle if any of the following
indicator lights are lit.
COMPLAINT
(A)
Product Door
Access Door
Element Up
Air Flow
(B)
Air Filter
Grease Filter
High Limit Reset
Fire System
Note: Power to the controller and heating element are electronically disconnected when:
- Access Door is Open
- Element is int he UP position
- Air Flow is below acceptable level
(A) The Product Door may be opened without interrupting the cooking cycle. However, cycle cannot
be started until product door is closed.
(B) Air Filter should be replaced at least every 3 months or sooner if volume is high.
CAUSE
1. Product Door Open
2. Failed switch
1. Access Door Open
2. Failed switch
1. Element in raised position
2. Failed switch
1. Fan failure
2. Failed switch
1. Air Filter not in place
2. Failed switch
1. Grease Filter not in place
2. Failed switch
1. Oil exceeded maximum
temperature
2. Probe Failure
1. 6 months operation has
elapsed.
- Air filter is not in place
- Grease filter is not in place
- High Limit Control has been tripped
12 - 2
Manual #16887 5/08 Rev 4/09
REMEDY
1. Close product door
2. Push power OFF button
Contact service person
1. Close Access door
2. Push power OFF button
Contact service person
1. Lower element
2. Push power OFF button
Contact service person.
1. Push power OFF button
Contact service person
2. Push power OFF button
Contact service person
1. Insert Air Filter all the way
2. Push power OFF button
Contact service person
1. Insert Grease Filter
2. Push power OFF button
Contact service person
Push power OFF
Contact service person
1. Contact certified Fire Ser-
vice Personnel for
required maintenance
inspection.