Troubleshooting - Suzuki GSF600Y 2000 Service Manual

6-20 ELECTRICAL SYSTEM
TROUBLE SHOOTING
Starter motor will not run.
The transmission is in neutral. Grasp the
clutch lever. Turn on the ignition switch with
the engine stop switch in the "RUN" position.
Listen for a click from the starter relay when
the starter button is pushed.
No click
Measure the starter relay voltage at the
starter relay connectors (between B/Y
and B/W ) when the starter button is
pushed.
Voltage
Check the starter relay.
( 6-23)
OK
The starter motor runs when the transmission is in neutral, but does not run when the transmission is
in any position other than neutral, with the side-stand up.
Check the side-stand switch.
( 6-25)
OK
Others
Engine does not turn though the
starter motor runs.
Clicks
No Voltage
No good
No good
Faulty side-stand switch
Check if the starter motor runs
when its terminal is connected to
the battery terminal (Do not use
a thin "wire" because a large
amount of current flows.)
Dose not run
Runs
Faulty starter motor
Faulty starter relay
Loose or disconnected starter
motor lead wire
Faulty ignition switch
Faulty engine stop switch
Faulty clutch lever position
switch
Faulty gear position switch
Faulty turn signal/side-stand
relay
Faulty starter button
Poor contact of connector
Open circuit in wire harness
Faulty starter relay
Poor contact of the starter relay
Faulty side-stand switch
Open circuit in wire harness
Poor contact of connector