Checking The Status Of Sockets Of Bulbs; Checking The Fuse - Yamaha FZ-16 Service Manual

Checking the status of sockets
of bulbs
The following procedure applies to all
sockets for light bulbs.
1. Check:
• bulb socket (for continuity)
(With multimeter)
No continuity Replace.
Multimeter
NOTE:
Check continuity of each socket of the
same manner as described in Section
the bulb, however, it should be noted
the following.
a. Install a good bulb in the socket.
b. Connect the multimeter probes to the
respective wires of the socket.
c. Check the continuity of the socket. If any
readings indicates no continuity,
replace the socket.

CHECKING THE FUSE

CAUTION:
To prevent a short circuit, always place
switch to "OFF" when
revise or replace a fuse.
1. Remove:
• Seat and right side cover
Refer to "GENERAL CHASSIS"
on page 4-1.
2. Check:
• Fuse
a. Connect the multimeter and check the fuse
continuity.
NOTE:
Set the multimeter to "Ù × 1".
Multimeter
b. If the meter shows "", replace the
fuse.
3. Replace:
• Blown fuse
ELECTRICAL COMPONENTS
a. Set the main switch to "OFF".
b. Install a new fuse of the correct amperage.
c. Setting the switches to verify if the
electrical circuit is operating.
d. If the fuse immediately remelted,
check the electrical circuit.
Article
Fuse
WARNING
Never use a fuse with an amperage
other than specified. Improvising or using
an incorrect amperage fuse may
cause serious damage to the electrical system,
cause a malfunction in the
lighting and ignition systems, and
could cause a fire.
4. Install:
• Seat and right cover
Refer to "GENERAL CHASSIS"
on page 4-1.
CHECKING AND CHARGING
WARNING
Batteries generate explosive hydrogen gas
and contain electrolyte which is toxic and acid
highly caustic sulfuric acid. Therefore, respecting
Always observe the following preventive measures:
•
Wear eye protection
when handling or working near batteries.
•
Charge batteries in a well ventilated area.
•
Keep batteries away from heat, sparks
or flames (eg welding equipment,
cigarettes).
•
Do not smoke while charging or handling batteries.
•
Keep batteries and electrolyte OUT OF
REACH OF CHILDREN.
•
Avoid body contact with the electrolyte, and
which can cause severe burns or injuries
permanent eye.
FIRST AID IF IN
BODY:
EXTERNAL
•
Skin - Wash with water.
•
Eyes - Flush with water for 15 minutes
and get immediate medical attention.
7-34
Classification
Amount
Amperage
15 A 1