Set Cable Free Play Clutch; Motor Oil Change; Free Play Adjustment Clutch Cable - Yamaha FZ-16 Service Manual

c. Assemble the new oil filter element
and cover of the oil filter element.
Cover screw element
Oil filter
10 Nm (1.0 m · kg, 7.2 ft · lb)
T.
R
7. Ensemble:
Drain Plug Washer
Drain Plug
20 Nm (2.0 m · kg, 14 ft · lb)
T.
R.
8. Filling:
Sump
(With the specified amount of oil
recommended)
Number of motor oil / quantity
Periodic oil change
1.00 lt
Total quantity of oil
9. Assembly:
Motor oil gauge
10.Arranque the engine, warm it up for some
minutes and then off.
11.Verifique
Engine
Engine Oil Leak)
12.Verificar:
Engine Oil Level
Refer to "CHECKING AND
ENGINE OIL LEVEL "in the
page 3-9
13.Check:
Engine oil pressure
a. Loosen screw check
oil "1".
1
b. Start the engine and idle until
the oil begins to seep from the screw
verification of oil. If it is not engine oil
after one minute, turn off the engine to
no damage occurs.
c. Check the engine oil passages, the
oil filter element and the pump
oil that is damaged or leaking. See
the "OIL PUMP" on page 5-43.
d. Start the engine after solving the
problem (s) and Pressure test
Engine oil again.
e. Tighten the torque verification
specified.
Oil check screw
7 Nm (0.7 m · kg, 5.1 ft · lb)
T.
R.
SET CABLE FREE PLAY
CLUTCH
1. Check:
Free play Clutch cable "to"
Set out of specification
Free play of the lever
clutch
10.0-15.0 mm
2. Adjust
Free play of clutch cable
Side of the handlebar
a. Pull back the rubber cover "1"
b. Loosen the lock nut "2"
c. Turn the adjustment screw "3" in the direction
"A" or "b" to obtain the free play
specified clutch cable.
Direction "a"
The cable free play of clutch
increases
Direction "b"
The cable free play of clutch
decreases
3-10
ENGINE
February 1
3
to
b