Vent Lines; Fuel System; Fuel Filter - Polaris RANGER RZR 170 Service Manual

Vent Lines

1. Check fuel tank,
transmission vent
deterioration, damage or leakage. Replace every two
years.
2. Verify vent lines are routed properly and secured with
cable ties.

Fuel System

WARNING
Gasoline is extremely flammable and explosive
under certain conditions.
Always stop the engine and refuel outdoors or in
a well ventilated area.
Do not smoke or allow open flames or sparks in
or near the area where refueling is performed or
where gasoline is stored.
Do not overfill the tank. Do not fill the tank neck.
If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
If you spill gasoline on your skin or clothing,
immediately wash it off with soap and water
and change clothing.
Never start the engine or let it run in an enclosed
area. Engine exhaust fumes are poisonous and
can result loss of consciousness or death
in a short time.
Never drain the fuel when the engine is hot.
Severe burns may result.
crankcase, carburetor
lines for signs of wear,
9923983 - 2012-2013 RZR 170 Service Manual
© Copyright 2012 Polaris Sales Inc.

Fuel Filter

and The fuel filter should be replaced in accordance with the
"Periodic Maintenance Chart" or whenever sediment is
visible in the filter.
Fuel Filter Location - Located in-line between fuel
pump and carburetor inlet.
To service the fuel filter:
1. Turn off fuel supply at fuel valve.
2. Remove line clamps at both ends of the filter.
3. Remove fuel lines from filter.
4. Install new filter and clamps onto fuel lines.
5. Turn fuel valve to 'ON'.
6. Start engine and inspect for leaks.
MAINTENANCE
2.15
2