Checking The Brake Fluid Level Of The Front Brake; Adding Front Brake Fluid - KTM 125 DUKE EU Repair Manual

14 BRAKE SYSTEM
14.3

Checking the brake fluid level of the front brake

Warning
Danger of accidents Failure of the brake system.
–
If the brake fluid level falls below the MIN mark, this indicates a leakage in the brake system or worn-out brake linings.
Check the brake system and do not continue riding.
Warning
Danger of accidents Reduced braking efficiency due to old brake fluid.
–
Change the brake fluid of the front and rear brake according to the service schedule.
14.4

Adding front brake fluid

Warning
Danger of accidents Failure of the brake system.
–
If the brake fluid level falls below the MIN mark, this indicates a leakage in the brake system or worn-out brake linings.
Check the brake system and do not continue riding.
Warning
Skin irritation Brake fluid can cause skin irritation on contact.
–
Avoid contact with skin and eyes, and keep out of the reach of children.
–
Wear suitable protective clothing and goggles.
–
If brake fluid comes into contact with the eyes, flush the eyes thoroughly with water and consult a physician immediately.
Warning
Danger of accidents Reduced braking efficiency due to old brake fluid.
–
Change the brake fluid of the front and rear brake according to the service schedule.
–
Position springs
The arrow on the spring points in the direction of travel.
–
Mount bolts
Info
Make sure the springs are seated correctly.
–
Activate the hand brake lever until there is a firm pressure point.
304813-10
–
Correct the brake fluid level to level
Guideline
Level
A
Brake fluid DOT 4 / DOT 5.1 (
–
Position the cover with the membrane. Mount and tighten the screws.
Info
Clean up overflowed or spilt brake fluid immediately with water.
304936-10
–
Move the brake fluid reservoir mounted on the handlebar to a horizontal position.
–
Check the brake fluid level in viewer
» If the brake fluid is below the MIN marking:
–
Add front brake fluid. (
C00200-10
.
6
.
5
.
A
p. 248)
.
1
p. 68)
5 mm (0.2 in)
68