Service Rules - Honda CBF600SA Service Manual

Manuals by Motomatrix / www.motomatrix.co.uk / The Solution For Lost Motorcycle Coded Keys.
GENERAL INFORMATION

SERVICE RULES

GENERAL INFORMATION
1. Use genuine Honda or Honda-recommended parts and lubricants or their equivalents. Parts that don't meet Honda's
design specifications may cause damage to the motorcycle.
2. Use the special tools designed for this product to avoid damage and incorrect assembly.
3. Use only metric tools when servicing the motorcycle. Metric bolts, nuts and screws are not interchangeable with
English fasteners.
4. Install new gaskets, O-rings, cotter pins, and lock plates when reassembling.
5. When tightening bolts or nuts, begin with the larger diameter or inner bolt first. Then tighten to the specified torque
diagonally in incremental steps unless a particular sequence is specified.
6. Clean parts in cleaning solvent upon disassembly. Lubricate any sliding surfaces before reassembly.
7. After reassembly, check all parts for proper installation and operation.
8. Route all electrical wires as show in the Cable and Harness Routing (page 1-24).
ABBREVIATION
Throughout this manual, the following abbreviations are used to identify the respective parts or systems.
Abbrev. term
ABS Anti-lock Brake System
CKP sensor Crankshaft Position sensor
DLC Data Link Connector
DTC Diagnostic Trouble Code
ECM Engine Control Module
ECT sensor Engine Coolant Temperature sensor
EEPROM Electrically Erasable Programmable Read Only Memory
EOP switch Engine Oil Pressure switch
HDS Honda Diagnostic System
HISS Honda Ignition Security System
IACV Idle Air Control Valve
IAT sensor Intake Air Temperature sensor
IDC solenoid valve Intake Duct Control solenoid valve
MAP sensor Manifold Absolute Pressure sensor
MIL Malfunction Indicator Lamp
PAIR Pulsed Secondary Air Injection
PCV Proportional Control Valve
PGM-FI Programmed Fuel Injection
SCS connector Service Check Short connector
TP sensor Throttle Position sensor
VS sensor Vehicle Speed sensor
1-2
email: info@motomatrix.co.uk
Full term