APRILIA RST mille Futura 2001 Service Manual page 268

CHASSIS
NOTE
Be extremely careful while removing the control
unit support, to avoid damaging the control unit.
Remove the radiator mount (6).
Remove both of the rider footrest supports, see 7.1.45
(REMOVING THE
SUPPORT) and see 7.1.46 (REMOVING THE RIGHT
RIDER FOOTREST SUPPORT).
NOTE
Release all cables from the clamps holding
them in place along their path. Have the same number of
clamps ready to use when reassembling.
Disconnect the electrical connector for the side stand
switch.
NOTE
When reassembling, make sure the electrical
connector is fitted properly.
NOTE
Be extremely careful while removing the side
stand support (8), to avoid damaging the switch.
Unscrew and remove the three screws (7) and remove
the side stand support (8), complete with side stand
and switch.
Tightening torque for screws (7): 29 ftlb (40 Nm).
Sling the frame (1) appropriately, and hook the slings to
a hoist for support.
NOTE
The slings and hoist must be sufficient to safely
support the entire frame (1).
Frame weight: 21.8 lb (9.9 Kg).
Raise the frame (1) just enough to be able to remove
the center support stand
Remove the center stand.
When you have finished re-installing the frame, proceed
as follows:
Make sure that all components are correctly fastened.
Make sure the cables and wiring are properly placed
and firmly fastened in place.
Make sure the electrical connectors are properly fitted.
Make sure that no cables or lines are pulled when
turning the handlebars.
DANGER
After the motorcycle is reassembled, turn the forks to
the full left and right positions with the engine
running. If turning from lock to lock causes any
change in the idle speed, the throttle cables are
improperly installed or adjusted. This problem must
be rectified before the motorcycle is used. Failure to
observe this WARNING can lead to a stuck throttle or
engine runaway, with subsequent upset, accident,
serious injury, or even death.
7
- 50 -
00
LEFT RIDER FOOTREST
.
5
2
3
6
8
RST mille
USA
4
1
7
Release 00/2002 - 03