Table of Contents
Advertisement
▀
Service and cleaning
Cut the power to the boiler before starting the service. We recommend a good service/cleaning
of the burner and boiler 2-3 times a year. Do as follows for best result and minimizing the
chances for failures.
Sweeping range
1. Firepbox, if necessary, or at about 3 tons of pel-
lets consumption.
2. Burner tubes after 3 tons of pellets consumption.
3. Convection part 3 tons of pellets consumption.
3. Without automatic cleaning every other week in
winter.
4. Soot box if necessary.
5. Smoke box after 3 tons of pellets consumption.
6. Flue pipe after 3 tons of pellets consumption.
7. The burner's outer tube 6 tons of pellets con-
sumption.
8. Flame detector after 6 tons of pellets consumption
(page 30)
Cleaning the firebox
Cleaning the firebox is done through the ash door on the front. The easiest way is to use some type
of ash cleaner. If you do not have access to a an ash cleaner, remove the ash with a scrape and keep
it in a fireproof bin. Remember that ashes can contain hot particles for a long time and may not be
stored near flammable materials.
Cleaning the burner
Remove the ash contained in the burner tube, this is done either through the firepbox with the supplied
scraper or by taking the burner tubes apart outside the boiler, which sometimes can be the easiest
way.
Cleaning of convection
Cleaning of the tubes is done with the included brush, lifting the turbulators acc. (page 12). It is
important for the efficiency that these are cleaned thoroughly at the service.
Cleaning of ash and flue
Soot box, which is placed above the tubes must be emptied of ash, if the soot box is full, the flue gas
has no place to escape out through the chimney and you will receive a disruption. Also clean the flue
tube that goes to the chimney, when it is not certain that the chimney sweep do it.
The burner's outer / innertube
The space between the outer - inner tube must be cleaned out of dust and particles after about 6 tons
of pellets consumption (page 32)
Effecta AB Västra Rågdalsvägen 21 434 99 Kungsbacka Sweden +46-300 - 22320 info@effecta.se
33
Advertisement
Table of Contents
