Engine Oil Level; Oil And Filter Change - Polaris A12MH46AX Service Manual

Engine Oil Level

A
The oil tank is located on the left side of the vehicle. To
check the oil level:
1. Set machine on a level surface.
2. Clean the area around the dip stick.
3. Start and run engine for 20-30 seconds. This will
return oil to its true level in the oil tank.
4. Stop engine, remove dipstick (A) and wipe dry with a
clean cloth.
5. Reinstall dipstick, screw the dipstick into place.
NOTE: The dipstick must be screwed completely in to
ensure accurate measurement.
NORMAL
ADD 8 OZ.
Maintain Oil Level In Normal range
Screw Dipstick in completely to check
6. Remove dipstick and check to see that the oil level is
in the normal range. The oil should be between the top
line and the bottom line on the dipstick. Add oil as
indicated by the level on the dipstick. Do not overfill.
NOTE: Rising oil level between checks in cool weather
driving, can indicate moisture collecting in the oil
reservoir. If the oil level is over the full mark, change the
oil.
FULL
9923412 - 2012 Sportsman 400/500 and EFI Tractor Service Manual
© Copyright 2011 Polaris Sales Inc.

Oil and Filter Change

Oil Filter Torque:
Turn by hand until filter gasket
contacts sealing surface, then
turn an additional 1/2 turn
Oil Filter Wrench:
(PV-43527)
Oil Tank Screen Fitting Torque:
25 ft-lb (34Nm)
Recommended Engine Oil:
Polaris PS 4 PLUS
Synthetic, 2W-5o
WARNING
Personal injury can occur when handling used
oil. Hot oil can cause burns or skin damage.
NOTICE: Care must be taken to ensure that the fluids are
contained. Be prepared to collect the fluid with suitable
containers before opening
disassembly of any component containing fluids.
1. Place vehicle on a level surface.
2. Clean area around drain plug (A) at bottom of oil tank.
3. Run engine two to three minutes until the engine is
warm.
4. After two or three minutes stop the engine.
5. Place a drain pan beneath oil tank and remove the
drain plug (A). CAUTION: Oil may be hot. Do not allow
hot oil to come into contact with skin as serious burns
may result.
B
A
6. Allow oil to drain completely.
MAINTENANCE
any compartment or
D
E
C
Reference mark
C
2.21
2