Fujitsu SCALEOVIEW S17-2 Operating Manual page 41

Periodic Inspections
Recommended
Frequency
Once a week, or
as notified about
a potential leak
Once a week or
after drive-offs
Once a week or
as required
MDE-3893P Encore® and Eclipse® Series Owner's Manual · December 2011
Components Recommended Maintenance
Leaks, outside 1. Inspect the following for leaks or signs of leakage:
the unit • Breakaways
• Couplings
• Hose outlet castings
• Hoses
• Nozzles
• Swivels
2. Look for any signs of fuel or fuel staining around
the base of the dispenser, especially at the side
columns and at the upper housing.
3. Review all documentation provided by each
component's manufacturer for additional
inspection information.
4. If a leak is found, stop using the unit, and make
arrangements to repair the leak.
CAUTION
WARNING
If you find a leak, stop using the pump/dispenser, and contact
your local ASC/CSC. Fire, explosion, or electrical shock could
result, if you continue to use a damaged pump/dispenser.
WARNING
Do not attempt to make these repairs yourself. Doing so could
result in severe injury or death.
Breakaways 1. Inspect breakaways for secure connection to
hose and for any leaks.
WARNING
If you find a leak, stop using the pump/dispenser, and contact
your local ASC/CSC. Fire, explosion, or electrical shock could
result, if you continue to use a damaged pump/dispenser.
2. Consult the breakaway manufacturer for any
additional required inspections.
Notes:
1. If repair is required, call an ASC/CSC.
2. Some breakaways are not repairable. Check with
the ASC/CSC whether the breakaway is
repairable before the ASC/CSC attempts to
reassemble the breakaway.
3. A leak inspection within the hydraulics cabinet is
also required. See the relevant section, later in
this chapter.
WARNING
Do not attempt to make these repairs yourself. Doing so could
result in severe injury or death.
Wash unit
Clean with Simple Green
equivalent). Do not wash with a high pressure hose.
Refer to "Performing General and Component
Maintenance Inspections"
Who Performs the
Inspection/Repair
• Owner—Inspect
• ASC/CSC only—Repair
and test
CAUTION
• Owner—Inspect
• ASC/CSC only—Repair
and test
CAUTION
CAUTION
® Owner
all purpose cleaner (or
on page 32.
Maintaining Units
Page 37