Generac Power Systems MLTS Owner's Manual page 5

Lowering the Mast—Manual Winch .................35
Lowering the Mast—Electric Winch (If Equipped)
35
Manually Lowering Electric Mast .............................. 35
Electronic Positive Air Shutdown (PAS)
(If Equipped) .......................................................36
Test the PAS ............................................................. 36
Reset the PAS .......................................................... 36
Coolant Heater or Engine Block Heater (If
Equipped) ...........................................................36
Tandem Tow (If Equipped) ................................37
Telemetry (If Equipped) .....................................37
Spark Arrester (If Equipped) .............................37
Heated Fuel Filter (If Equipped) ........................37
Towing the Unit ..................................................37
Lifting the Unit ...................................................38
Tying Down the Unit ..........................................39
Section 4: Maintenance
Emissions Information ...................................... 41
Daily Walk-Around Inspection ..........................41
General Maintenance .........................................41
Preparing for Service ................................................ 41
Cleaning the Unit ...................................................... 41
Inspecting the Unit .................................................... 41
Basic Maintenance Schedule ........................... 42
Manual Winch: Use, Operation, and Maintenance
43
Prior to Use ............................................................... 43
Operation .................................................................. 43
Maintenance ............................................................. 43
Electric Winch (If Equipped): Use, Operation, and
Maintenance .......................................................43
Winch Mechanical Brake .......................................... 44
Trailer Wheel Bearings ...................................... 45
Jack Maintenance ..............................................45
Section 5: Troubleshooting
General Troubleshooting ..................................47
Troubleshooting the Lights ..............................48
Troubleshooting Controller Fault Indicators ..49
iv
Section 6: Wiring Diagrams
Mast Junction Box Wiring and Light Connec-
tions .................................................................... 51
MLTS-K AC Analog Wiring ............................... 52
MLTS-K DC Analog Wiring ............................... 53
MLTS-K AC Digital Wiring ................................ 54
MLTS-K DC Digital Wiring ................................ 55
MLTS AC Wiring (No-Export Power) (1 of 3) ... 56
MLTS AC Wiring (Export Power) (2 of 3) ......... 57
MLTS AC Wiring (240 VAC Input Power) (3 of 3)
58
MLTS DC Analog Wiring ................................... 59
MLTS AC Wiring—Power Zone (If Equipped) (1 of
3) ......................................................................... 60
MLTS AC Wiring—Power Zone (If Equipped) (2 of
3) ......................................................................... 61
MLTS AC Wiring—Power Zone (240 Shore Power
If Equipped) (3 of 3) ........................................... 62
MLTS AC Wiring—Power Zone (120 Shore Power
If Equipped) ........................................................ 63
MLTS DC Wiring—Power Zone (If Equipped) 64
MLTS Trailer Lights ........................................... 65
Section 7: NHTSA Trailer Equipment
Requirements
Reporting Safety Defects to the United States
Government ....................................................... 58
Tire Safety Information ..................................... 58
Steps for Determining Correct Load Limit – Trailer .. 58
Steps for Determining Correct Load Limit – Tow Vehicle
59
Glossary of Tire Terminology .................................... 59
Tire Safety ................................................................ 61
Owner's Manual for Mobile Light Tower