Extend O/R Solenoid Open Circuit; Extend O/R Solenoid Short To Battery - JLG T350 Troubleshooting Manual

2.45 EXTEND O/R SOLENOID OPEN CIRCUIT

Distress Lamp: 9
Ground module feedback shows that Extend Outrigger digital output may be disconnected from the relay or the relay may
be defective.
Functions Disabled: Set (Extend O/R)
Step Pretest Instructions
2.45.1 Run system test
2.45.2 Disconnect solenoid at X086.
Short X086.1.soc to
X086.2.soc
2.45.3 Replace X003.13 with a
jumper to X003.3

2.46 EXTEND O/R SOLENOID SHORT TO BATTERY

Distress Lamp: 9
Ground module feedback shows that the Extend Outrigger Valve digital output may be shorted to battery or the solenoid
may be defective.
Functions Disabled: Set (Extend O/R)
Step Pretest Instructions
2.46.1 Run system test
2.46.2 Disconnect solenoid at X086
and isolate wires
2.46.3 Remove wire Orn/Wht 55-3-1
from X003.13
3121203
SECTION 2 - TROUBLESHOOTING BY FAULT MESSAGES
ADE Code: 3-3
Test
Do other functions fail sys-
tem test?
Rerun System Test
Rerun System Test
ADE Code: 3-3
Test
Do other functions fail sys-
tem test?
Rerun System Test
Rerun System Test
T350 T500J
Result
Yes
No
Analyzer Message "EXTEND
VALVE SHORT TO GROUND"
Analyzer Message "EXTEND
VALVE OPEN CIRCUIT"
Analyzer Message "EXTEND
VALVE SHORT TO GROUND"
Analyzer Message "EXTEND
VALVE OPEN CIRCUIT"
Result
Yes
No
Analyzer Message "EXTEND
VALVE OPEN CIRCUIT"
Analyzer Message "EXTEND
VALVE SHORT TO BATTERY"
Analyzer Message "EXTEND
VALVE OPEN CIRCUIT"
Analyzer Message "EXTEND
VALVE SHORT TO BATTERY"
Corrective Action
Possible Cause: Black ground wire
broken, 4.1.1, otherwise
Go to step 2.45.2
Go to step 2.45.2
Replace solenoid and/or connector
Go to step 2.45.3
Wire Orn/Wht 55-3-1 or Orn/Wht 55-3
broken. Repair or replace
Possible Cause: 4.1.10
Corrective Action
Possible Cause: Black ground wire
broken, 4.1.1, otherwise go to step
2.46.2
Go to step 2.46.2
Replace solenoid
Go to step 2.46.3
Wire Orn/Wht 55-3-1 or Orn/Wht 55-3
shorted to battery. Repair or replace
Possible Cause: 4.1.10
2-61