Section 2 - Troubleshooting By Fault Messages; Accessory Fault; Battery Voltage Too High - System Shutdown; Battery Voltage Too Low - System Shutdown - JLG T350 Troubleshooting Manual

SECTION 2.

2.1 ACCESSORY FAULT

Distress Lamp: 9
An attached accessory is communicating a fault to the ground control.
Step Pretest Instructions
2.1.1

2.2 BATTERY VOLTAGE TOO HIGH - SYSTEM SHUTDOWN

Distress Lamp: 3
The system detected a battery voltage above 36 Volts for an electric powered machine.
ELECTRIC POWERED MACHINES ONLY
Functions Disabled (Electric Powered Machines Only): Lift Up, Lift Down, Swing Left, Swing Right, Telescope In, Telescope
Out, Jib Up, Jib Down, Level Up, Level Down, Front Left O/R, Front Right O/R, Rear Left O/R, Rear Right O/R, Set (Extend O/
R), Stow (Retract O/R), Drive
Possible Causes: 4.1.2, 4.1.3, 4.1.4
2.3 BATTERY VOLTAGE TOO HIGH - SYSTEM SHUTDOWN
Distress Lamp: 5
The system detected a battery voltage above 18 Volts for an engine powered machine.
ENGINE POWERED MACHINES ONLY
Functions Disabled (Engine Powered Machines Only): Lift Up, Lift Down, Swing Left, Swing Right, Telescope In, Telescope
Out, Jib Up, Jib Down, Level Up, Level Down, Front Left O/R, Front Right O/R, Rear Left O/R, Rear Right O/R, Set (Extend O/
R), Stow (Retract O/R), Engine Start, Engine Throttle Pull, Engine Throttle Hold, Engine Choke Pull, Engine Choke Hold,
Drive
Possible Causes: 4.1.2, 4.1.3, 4.1.4

2.4 BATTERY VOLTAGE TOO LOW - SYSTEM SHUTDOWN

Distress Lamp: 3
The system detected a battery voltage below 16 Volts for an electric powered machine.
ELECTRIC POWERED MACHINES ONLY
Functions Disabled (Electric Powered Machines Only): Lift Up, Lift Down, Swing Left, Swing Right, Telescope In, Telescope
Out, Jib Up, Jib Down, Level Up, Level Down, Front Left O/R, Front Right O/R, Rear Left O/R, Rear Right O/R, Set (Extend O/
R), Stow (Retract O/R), Drive
Possible Causes: 4.1.2, 4.1.3, 4.1.4
3121203

SECTION 2 - TROUBLESHOOTING BY FAULT MESSAGES

TROUBLESHOOTING BY FAULT MESSAGES
ADE Code: 6-7
Test
Is an accessory installed?
ADE Code: 4-4
ADE Code: 4-4
ADE Code: 4-4
T350 T500J
Result
Yes
No
Corrective Action
Refer to Information Supplied with
Accessory
Possible Causes: 4.1.2
2-41