Volvo Penta D13 Series Operator's Manual page 95

Carbon monoxide poisoning
Only start the engine in a well-ventilated area. If
operating the engine in an enclosed space, ensure
that there is proper ventilation in order to remove
exhaust gases and crankcase ventilation emissions
from the working area.
Chemicals
Most chemicals such as anti-freeze, rustproofing
agent, inhibiting oil, degreasing agent etc. are
hazardous to health. Read and follow the instructions
on the packaging.
Some chemicals such as inhibiting oil are inflammable
and dangerous if breathed in as well. Ensure good
ventilation and use a protective mask when spraying.
Read and follow the instructions on the packaging.
Store chemicals and other hazardous materials out of
the reach of children. To protect the environment,
please dispose of used or leftover chemicals at a
properly designated disposal site for destruction.
Cooling system
There is a risk of flooding when working on the
seawater system. Turn off the engine and close the
sea cock (where installed) before starting work on the
system.
Avoid opening the coolant filler cap when the engine
is hot. Steam or hot coolant can spray out and cause
burns.
If work must be carried out with the engine at
operating temperature and the coolant filler cap or a
cock open or a coolant hose disconnected, open the
coolant filler cap carefully and slowly to release
pressure before removing the cap completely. Note
that the coolant may still be hot and can cause burns.
Fuel system
Always use protective gloves when tracing leaks.
Liquids ejected under pressure can penetrate body
tissue and cause serious injury. There is a danger of
blood poisoning.
Always cover the generator if it is located under the
fuel filter. The generator can be damaged by spilled
fuel.
The engine and the area around the engine must be
kept clean from fuel to avoid accidents, engine
damage and injuries.
47708638 09-2016 © AB VOLVO PENTA
Electronic Vessel Control (EVC)
The boat has a advanced control system. Never cut
or modify connectors, wiring or splice of the
components.
Installing components that do not comply with the
quality for Volvo Penta original spare parts may cause
the system to malfunction. We strongly recommend
to use Volvo Penta original spare parts.
Electrical system
Cutting off power
Always stop the engine and break the current using
the main switches before working on the electrical
system. Isolate shore current to the engine block
heater, battery charger, or accessories mounted on
the engine.
Batteries
The batteries contain an extremely corrosive
electrolyte. Protect your skin and clothes when
charging or handling batteries. Always use protective
goggles and gloves.
If battery electrolyte comes into contact with
unprotected skin, wash off immediately using plenty
of water and soap. If battery acid comes into contact
with the eyes, flush immediately with plenty of water
and obtain medical assistance without delay.
The batteries contain and emit oxyhydrogen gas,
especially during charging. This gas is easily ignited
and highly volatile.
Do not under any circumstances smoke or use naked
flame or allow sparks in the vicinity of the batteries or
battery compartment.
An incorrect connection of a battery terminal cable or
jump-start cable can cause a spark which in its turn
can be sufficient to cause an explosion.
Maintenance
93