Maintenance And Care; Preventive Maintenance - Dantherm HCH 5 MKII Manual

INSTALLATION & SERVICE MANUAL FOR PROFESSIONALS
Maintenance and care: Preventive maintenance
Operating the
See user manual section "Operation" on page 8.
device

Preventive maintenance

Introduction Preventive maintenance is necessary at regular intervals if the unit is to operate efficiently
and optimally without unintended downtime and to ensure the expected service life of at
least 10 years.
It is important to notice that intervals between filter maintenance can vary according to the
specific environment, and that moving parts are wearing parts, and will need replacement
when worn.
The factory warranty only applies if it can be documented that regular preventive mainte-
nance has been carried out as prescribed. The documentation can be written in a logbook
containing a company stamp or equivalent.
Summary of
Maintenance must at minimum be carried out as shown here:
intervals
Interval
Six
months
Electric preheater
Annual
(2 years)
2 years
Injury caused by electric shock and risk of damage to the device
WARNING
• An inspection must be carried out every two years by trained professionals only.
• Disconnect mains plug from electrical outlet before carrying out maintenance or repair.
• If the power supply cable is damaged, it must be replaced by the manufacturer, its service
• Make sure that all work has finished and that styrene front lid and metal front cover are
Operation

Maintenance and care

Task
Check filters. Replace if necessary
Change filters
Inspect and clean fans
Inspect and clean electrical preheater
Inspect and clean heat exchanger
Clean the internal air direction
Inspect and clean drip tray, drain and drain hose
Inspect and clean bypass
agent or similarly qualified persons in order to avoid a hazard.
fully mounted before turning on the power supply again
To be carried out by:
User
User
Trained professionals
Trained professionals
Trained professionals
Trained professionals
Trained professionals
Trained professionals
39