Audi TT 2007 Workshop Manual page 71

♦ Gear oil for direct shift gearbox 02E, Part No. ⇒ Parts cata‐
logue
Procedure
Proceed as follows:
Note
Observe general repair instructions
♦
Observe rules for cleanliness when working on the gearbox
♦
⇒ page 10 .
Observe notes on direct shift gearbox 02E, "Regulations for
♦
the disposal of oil" ⇒ page 5
Use only the correct type of gear oil for the direct shift gearbox
♦
02E (available as a replacement part). Other types of oil cause
malfunctions and/or failure of the gearbox.
WARNING
Hot gearbox oil can cause burns.
♦ Wear safety goggles.
♦ Wear protective gloves (acid resistant).
Accidents can be caused if a gear is inadvertently engaged
while the engine is running.
♦ Before working on the vehicle while the engine is running,
shift the selector lever into position "P" and apply the
handbrake.
Caution
Risk of damage to the gearbox.
♦ The engine must NOT be started if there is only little or no
oil left in the gearbox after repair work or after excessive
loss of oil.
♦ After repair work or after excessive loss of oil, put in a
suitable amount of gear oil before proceeding.
• Gearbox not in backup mode (emergency running mode)
• Vehicle must be on a 4-pillar lifting platform or standing over
an inspection pit so it is absolutely horizontal.
• Selector lever in position "P", handbrake applied.
Direct shift gearbox 02E, front-wheel drive - Edition 12.2006
⇒ page 8 .
.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Audi TT 2007 ➤
67
9.